262, REV G Effective Date: May 20, Page: 1 of 5 series, DM500, DM550, DM800, DM900 and DM1000 mailing machines

Transcription

1 Page: 1 of 5 DM900 and DM1000 mailing SECTION 1 IDENTIFICATION OF THE SUBSTANCE/PREPARATION AND OF THE COMPANY/UNDERTAKING Series, DM500, DM550, DM800, DM900 and DM1000 mailing Reorder 621-1: DE95006 for the DM500 and DM : DT84037 for the DM800, DM900 and DM : FRDP-7M for the DM100 series Single Pack, Twin Pack Manufacturer: Pitney Bowes Inc. Address and Phone: 1 Elmcroft Road Stamford, CT United States Emergency/Chemtrec: North America For SDS Copies: (go to search) For Additional ehs@pb.com Information: Use: Ink for Mailing Machines MSDS Prepared By: Chemical Review Board WHMIS Reviewed July 30, 2007 Pitney Bowes Ltd The Pinnacles Harlow Essex, CM19 5BD +44 (0) International (collect call) SECTION 2 HAZARDS IDENTIFICATION Emergency Overview: A red ink with a slight odor. This ink is not flammable or combustible. May cause mild eye and skin irritation. Direct contact may stain tissues. EU Preparation Classification Not Classified as Dangerous (1999/45/EC): SECTION 3 COMPOSITION/INFORMATION ON INGREDIENTS INGREDIENT NAME CAS NO./EINECS NO. % EC SUBSTANCE CLASSIFICATION (67/548/EEC) / None Surfactant Poly(oxy-1,2- ethanediyl), alpha, alpha -(1,4- dimethyl-1,4-bis(2- methylpropyl)-2-butyne-1,4- diyl)bis(omega-hydroxy) Xi R41

2 Page: 2 of 5 Dye Hexasodium 2,2 -(( / Xi R41 morpholino-1,3,5-triazine-2,4- diyl)bis(imino(2-sulphonato- 4,1-phenylene)vinylene(3- sulphonato-4,1- phenylene)))bis(2h- naphtho(1,2-d)triazole-5- sulphonate) Heterocyclic Compound Proprietary 5-10 Water and non-hazardous polymers Mixture Balance None See Section 16 for full text of EC Classification and R Phrases SECTION 4 FIRST AID MEASURES Eyes: Immediately flush with plenty of cool water, holding eyelids open to assure thorough rinsing. Get medical attention if irritation persists. Skin: Wash with soap and water. Ingestion: If swallowed, dilute with water. DO NOT induce vomiting. Never give fluids or induce vomiting if the victim is unconscious or having convulsions. Get medical attention. Inhalation: Not an expected route of entry. If symptoms are experienced, move victim to fresh air and get medical attention. SECTION 5 FIRE FIGHTING PROCEDURES Extinguishing Media: Use media appropriate for surrounding fire. Fire Fighting Instructions: Firefighters should wear positive pressure self- contained breathing apparatus and full protective clothing for fires in areas where chemicals are used or stored. Cool fire exposed containers with water. Unusual Fire and Explosion None known. Hazards: Known or Anticipated Carbon and nitrogen oxides. Hazardous s of Combustion: SECTION 6 ACCIDENTAL RELEASE MEASURES Accidental Release Measures: Contain spill. Personal Precautions: Avoid contact with eyes and skin. Environmental Precautions: It is recommended to keep away from drains, surface and groundwater. Methods for Cleanup: Large Spill: Contain spill and absorb with an inert absorbent. Place in an appropriate container for proper disposal. Small Spill: Soak up any small amounts with absorbent material

3 Page: 3 of 5 SECTION 7 HANDLING AND STORAGE Handling: Avoid contact with eyes, skin and clothing. If contact occurs, wash immediately. Storage: Store in a cool, dry place. Keep out of the reach of children. Other Precautions: None. SECTION 8 - EXPOSURE CONTROLS & PERSONAL PROTECTION Occupational Exposure Limits: United States United Kingdom Australia Surfactant Poly(oxy-1,2- ethanediyl), alpha, alpha -(1,4- dimethyl-1,4-bis(2-methylpropyl)-2- butyne-1,4-diyl)bis(omega-hydroxy) Dye Hexasodium 2,2 -((6- morpholino-1,3,5-triazine-2,4- diyl)bis(imino(2-sulphonato-4,1- phenylene)vinylene(3-sulphonato- 4,1-phenylene)))bis(2H- naphtho(1,2-d)triazole-5- sulphonate) Heterocyclic Compound Water and non-hazardous colorant Engineering Controls: Ventilation Requirements: Personal Protective Equipment: Eye/Face Protection: Skin Protection: Respiratory Protection: Other Protective Clothing or Equipment: 5 mg/m3 (respirable), 15 mg/m3 (total) TWA OSHA PEL 10 mg/m3 TWA ACGIH TLV 10 mg/m3 TWA 10 mg/m3 TWA None required. General office ventilation. SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES Appearance: Red ink with a slight odor. Boiling Point: Freezing Point: Octanol/Water Partition Coefficient: None normally required. If splashing is possible, wear safety glasses. None normally required. Wear rubber gloves if needed to avoid prolonged or repeated contact. Not required. Not required.

4 Page: 4 of 5 Odor: Slight odor Percent Volatile: 65-85% ph Value: 7-9 Solubility in Water: Miscible Specific Gravity or Density (Water=1): Vapor Density: Vapor Pressure: Volatile Organic Compounds: Flammable Limits in Air (% by Volume): Flash Point: None Autoignition Temperature: SECTION 10 STABILITY AND REACTIVITY Stability: Stable Incompatibility With Other Oxidizing materials, acids, bases and reducing agents. Materials: Hazardous Decomposition Carbon monoxide and carbon dioxide s: Hazardous Polymerization: Will not occur. SECTION 11 TOXICOLOGICAL INFORMATION Relevant Routes of Exposure: Eye, skin, inhalation, ingestion Potential Health Effects: Eyes: May cause mild eye irritation. Not an eye irritant in experimental animals. Direct contact may stain tissues. Skin: May cause mild skin irritation. Not a skin irritant in experimental animals. Direct contact may stain tissues. Ingestion: Swallowing large amounts may cause abdominal pain, headache, dizziness, drowsiness, dullness, nausea, vomiting and diarrhea. Inhalation: No adverse effects expected under normal use. High vapor concentrations due to heating may cause respiratory irritation, coughing, headache, dizziness, drowsiness and nausea. Medical Conditions Generally None expected Aggravated By Exposure: Carcinogenicity: None of the component of this product are classified as carcinogens by IARC, OSHA, NTP, ACGIH, or the EU Directives. Acute Toxicity Data The data reported below is the available data for the product components obtained from the published literature. VALUE ANIMAL ROUTES COMPONENTS LD50: No data available LC50: No data available Oral Dermal

5 Page: 5 of 5 LD50: 12,600 mg/kg LD50: >10,000 mg/kg Rat Rabbit Oral Dermal Additional Information Note: This product has been found to be negative in skin sensitization tests with guinea pigs. This product tested negative in the AMES test for mutagenicity. SECTION 12 - ECOLOGICAL INFORMATION Ecological Information: No data available. SECTION 13 - DISPOSAL CONSIDERATIONS Disposal Considerations: Dispose in accordance with local, state or provincial and federal or national regulations. SECTION 14 - TRANSPORT INFORMATION Not regulated for transportation under IATA/ICAO, IMDG, US DOT, EU ADR, or Canadian TDG Regulations. SECTION 15 - REGULATORY INFORMATION EU Regulations: All the components are listed on the EINECS inventory. EU Labeling: German WGK: Canadian Regulations: U.S. Federal Regulations: US State Regulations: Not classified as a dangerous preparation. This product is considered a manufactured article and not subject to CEPA or WHMIS. This product contains chemical or chemical compounds listed in the following SARA Title III categories: Extremely Hazardous Substances (302): None Toxic Chemical Release Reporting (313): None SARA 311/312 Hazards: Acute Health TSCA: All the components of this product are listed in the EPA TSCA Inventory. This product does not contain any chemicals subject to California Proposition 65. SECTION 16 - OTHER INFORMATION NFPA Codes: Health: 1 Fire: 0 Reactivity: 0 HMIS Codes: Health: 1 Fire: 0 Reactivity: 0 EU Classes and Risk Phrases for Xi Irritant Reference (See Sections 2 and 3): R41 Risk of serious damage to eyes Other Information: Keep out of reach of children.