Safety data sheet according to 1907/2006/EC, Article 31. Printing date Revision:

Transcription

1 Page 1/8 SECTION 1: Identification of the substance/mixture and of the company/ undertaking 1.1 Product identifier 1.2 Relevant identified uses of the substance or mixture and uses advised against Application of the substance / the mixture Construction chemicals 1.3 Details of the supplier of the safety data sheet Manufacturer/Supplier: Saint-Gobain Weber Limited Dickens House Enterprise Way Flitwick Bedfordshire MK45 5BY 1.4 Emergency telephone number: Product safety department SECTION 2: Hazards identification 2.1 Classification of the substance or mixture Classification according to Regulation (EC) No 1272/2008 Results of in vitro- tests have shown that cement based mixtures with more than 1% of cement cause serious skin irritation and serious eye damage, therefore the classification of these mixtures regarding H315 and H318 is not based on the calculation of the ingredients or the ph in this case. ~ Eye Dam. 1 GHS05 corrosion H318 Causes serious eye damage. ~ GHS07 Skin Irrit. 2 H315 Causes skin irritation. Skin Sens. 1 H317 May cause an allergic skin reaction. STOT SE 3 H335 May cause respiratory irritation. Classification according to Directive 67/548/EEC or Directive 1999/45/EC Information concerning particular hazards for human and environment: The product has to be labelled due to the calculation procedure of the "General Classification guideline for preparations of the EU" in the latest valid version. Classification system: The classification is according to the latest editions of the EU-lists, and extended by company and literature data. 2.2 Label elements Labelling according to Regulation (EC) No 1272/2008 The product is classified and labelled according to the CLP regulation. (Contd. on page 2)

2 Page 2/8 Hazard pictograms ~ ~ GHS05 GHS07 (Contd. of page 1) Signal word Danger Hazard-determining components of labelling: cement portland, grey Hazard statements H315 Causes skin irritation. H318 Causes serious eye damage. H317 May cause an allergic skin reaction. H335 May cause respiratory irritation. Precautionary statements P261 Avoid breathing dust. P280 Wear protective gloves/protective clothing/eye protection/face protection. P305+P351+P338 IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. P310 Immediately call a POISON CENTER/doctor. P363 Wash contaminated clothing before reuse. P501 Dispose of contents/container in accordance with local/regional/national/ international regulations. 2.3 Other hazards Results of PBT and vpvb assessment PBT: vpvb: SECTION 3: Composition/information on ingredients 3.2 Chemical characterisation: Mixtures Description: Mixture: consisting of the following components. Dangerous components: CAS: EINECS: cement portland, grey?@g?@g Xi R37/38-41;?@G?@G Xi R43 ~ Eye Dam. 1, H318; ~ Skin Irrit. 2, H315; Skin Sens. 1, H317; STOT SE 3, H % Additional information The preparation is "low chromate" according to 2006/1907/EEC within the product shelf-life, so that the identification with R 43 (H317 + EUH203) is not applicable, when the packing was not opened in the meantime. For the wording of the listed risk phrases refer to section 16. (Contd. on page 3)

3 Page 3/8 (Contd. of page 2) SECTION 4: First aid measures 4.1 Description of first aid measures General information Remove the victim immediately from the danger area. If the patient is unwell consult a doctor and present this data sheet. After inhalation Supply fresh air; consult doctor in case of complaints. After skin contact Generally the product does not irritate the skin. After eye contact Rinse opened eye for several minutes under running water. Rinse liquid should be tempered (20-30 C). After swallowing If symptoms persist consult doctor. 4.2 Most important symptoms and effects, both acute and delayed 4.3 Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1 Extinguishing media Suitable extinguishing agents CO2, powder or water spray. Fight larger fires with water spray or alcohol resistant foam. 5.2 Special hazards arising from the substance or mixture 5.3 Advice for firefighters Protective equipment: No special measures required. SECTION 6: Accidental release measures 6.1 Personal precautions, protective equipment and emergency procedures Not required. 6.2 Environmental precautions: No special measures required. 6.3 Methods and material for containment and cleaning up: Pick up mechanically. 6.4 Reference to other sections See Section 7 for information on safe handling See Section 8 for information on personal protection equipment. See Section 13 for disposal information. SECTION 7: Handling and storage 7.1 Precautions for safe handling Provide suction extractors if dust is formed. Information about fire - and explosion protection: No special measures required. 7.2 Conditions for safe storage, including any incompatibilities Storage Requirements to be met by storerooms and receptacles: Store only in unopened original receptacles. Information about storage in one common storage facility: Not required. Further information about storage conditions: None. (Contd. on page 4)

4 Page 4/8 7.3 Specific end use(s) (Contd. of page 3) SECTION 8: Exposure controls/personal protection Additional information about design of technical facilities: No further data; see item Control parameters Ingredients with limit values that require monitoring at the workplace: CAS No. Designation of material % Type Value Unit cement portland, grey WEL Long-term value: 10* 4** mg/m³ *inhalable dust **respirable dust Additional Occupational Exposure Limit Values for possible hazards during processing: Quartz alveolar dust (< 5 µm) : 0,15 mg/m³ Additional information: The applicable TRGS 900 (MAK list) was used as the basis for the preparation and/or revision of this safety data sheet. 8.2 Exposure controls Personal protective equipment: General protective and hygienic measures: The usual precautionary measures are to be adhered to when handling chemicals. Wash hands before breaks and at the end of work. Respiratory protection: Not required. Protection of hands: Protective gloves. Eye protection: Tightly sealed goggles Body protection: Protective work clothing. SECTION 9: Physical and chemical properties 9.1 Information on basic physical and chemical properties General Information Appearance: Form: Powder Colour: Grey Odour: Characteristic Odour threshold: ph-value: Change in condition Melting point/melting range: Boiling point/boiling range: Flash point: Flammability (solid, gaseous): Ignition temperature: Decomposition temperature: Undetermined. Undetermined. Not applicable Product is not flammable. (Contd. on page 5)

5 Page 5/8 Self-igniting: Danger of explosion: Explosion limits: Lower: Upper: Oxidising properties Vapour pressure: Density: Relative density Vapour density Evaporation rate Solubility in / Miscibility with Water: Segregation coefficient (n-octanol/water) log Pow: Product is not selfigniting. Product does not present an explosion hazard. Unsoluble Viscosity: dynamic: kinematic: Solvent content: Organic solvents: 0.0 % EU-VOC 0.00 % Solids content: % 9.2 Other information (Contd. of page 4) SECTION 10: Stability and reactivity 10.1 Reactivity 10.2 Chemical stability Stable at recommended storage conditions Thermal decomposition / Conditions to be avoided: No decomposition if used according to specifications Possibility of hazardous reactions No dangerous reactions known 10.4 Conditions to avoid 10.5 Incompatible materials: 10.6 Hazardous decomposition products: No dangerous decomposition products known. SECTION 11: Toxicological information 11.1 Information on toxicological effects Acute toxicity: Primary irritant effect: on the skin: Irritant to skin and mucous membranes. on the eye: Strong irritant with the danger of severe eye injury. (Contd. on page 6)

6 Page 6/8 Sensitisation: No sensitising effects known. (Contd. of page 5) SECTION 12: Ecological information 12.1 Toxicity Aquatic toxicity: 12.2 Persistence and degradability 12.3 Bioaccumulative potential Behaviour in environmental systems: 12.4 Mobility in soil Additional ecological information: General notes: Do not allow product to reach ground water, water course or sewage system Results of PBT and vpvb assessment PBT: vpvb: 12.6 Other adverse effects SECTION 13: Disposal considerations 13.1 Waste treatment methods European waste catalogue Possible waste code. The concrete waste code depends of the source of the waste. Uncleaned packaging: Recommendation: Empty contaminated packagings thoroughly. They may be recycled after thorough and proper cleaning. Recommended cleaning agent: Thoroughly shake out sacks. SECTION 14: Transport information 14.1 UN-Number ADR, IMDG, IATA 14.2 UN proper shipping name ADR, IMDG, IATA 14.3 Transport hazard class(es) ADR Class - (-) IMDG Class Label - IATA Class (Contd. on page 7)

7 Page 7/ Packing group ADR, IMDG, IATA 14.5 Environmental hazards: 14.6 Special precautions for user EMS Number: Transport in bulk according to Annex II of MARPOL73/78 and the IBC Code Transport/Additional information: UN "Model Regulation": UN-, - (Contd. of page 6) Not dangerous according to the above specifications. SECTION 15: Regulatory information 15.1 Safety, health and environmental regulations/legislation specific for the substance or mixture 15.2 Chemical safety assessment: A Chemical Safety Assessment has not been carried out. SECTION 16: Other information This information is based on our present knowledge. However, this shall not constitute a guarantee for any specific product features and shall not establish a legally valid contractual relationship. Relevant phrases H315 Causes skin irritation. H317 May cause an allergic skin reaction. H318 Causes serious eye damage. H335 May cause respiratory irritation. R37/38 Irritating to respiratory system and skin. R41 Risk of serious damage to eyes. R43 May cause sensitisation by skin contact. Department issuing MSDS: Product safety department. Contact: Dr Sara Kelly SHEQ Systems Manager weber Tel: Fax: sara.kelly@netweber.co.uk Abbreviations and acronyms: ADR: Accord européen sur le transport des marchandises dangereuses par Route (European Agreement concerning the International Carriage of Dangerous Goods by Road) IMDG: International Maritime Code for Dangerous Goods IATA: International Air Transport Association GHS: Globally Harmonised System of Classification and Labelling of Chemicals (Contd. on page 8)

8 Page 8/8 EINECS: European Inventory of Existing Commercial Chemical Substances ELINCS: European List of Notified Chemical Substances CAS: Chemical Abstracts Service (division of the American Chemical Society) PBT: Persistent, Bioaccumulative and Toxic vpvb: very Persistent and very Bioaccumulative Skin Irrit. 2: Skin corrosion/irritation, Hazard Category 2 Eye Dam. 1: Serious eye damage/eye irritation, Hazard Category 1 Skin Sens. 1: Sensitisation - Skin, Hazard Category 1 STOT SE 3: Specific target organ toxicity - Single exposure, Hazard Category 3 (Contd. of page 7)