Denatured Ethanol Group Standard HSR002553

Transcription

1 Denatured Ethanol Group Standard HSR GROUP STANDARD UNDER THE HAZARDOUS SUBSTANCES AND NEW ORGANISMS ACT 1996

2 Denatured Ethanol Group Standard 2017 Denatured Ethanol Group Standard HSR Pursuant to clause 5 of Schedule 7 of the Hazardous Substances and New Organisms Act 1996 (the Act), the Environmental Protection Authority has reviewed and, for the purpose of updating, reissues this Group Standard. Table of Contents 1. Name of Group Standard Commencement Interpretation Scope of Group Standard Conditions of Group Standard... 2 Schedule 1: Conditions of Group Standard... 3 Part 1 - Compliance with EPA Notices Labelling and advertising Safety Data Sheets Packaging Disposal Restrictions on supply, storage and use... 4 Part 2 - Other Matters Assigning a substance to a group standard... 4 Schedule 2: Interpretation... 5 Explanatory note... 6 December 2017

3 1. Name of Group Standard Denatured Ethanol Group Standard 2017 HSNO Approval Number The HSNO Approval Number for this Group Standard is HSR Commencement This Group Standard comes into force on 1 December Interpretation (1) In this Group Standard, unless the context otherwise requires, words and phrases shall have the meanings given to them in Schedule 2. Any words or phrases that are used but not defined in this Group Standard but that are defined in the Act have the same meaning as the Act. (2) In this Group Standard, references to a hazardous property of a substance being equivalent to a specified HSNO hazard classification, means a reference to the specified hazard classification as set out in the Hazardous Substances (Classification) Notice Scope of Group Standard Substances covered by Group Standard (1) This Group Standard applies to hazardous substances under section 96B(2)(a), (b) and (c) of the Act. (2) This Group Standard applies to denatured ethanol products. (3) A substance referred to in subclause (2) must be (a) a flammable liquid with a flashpoint of less than 23 C and an initial boiling point of greater than 35 C (HSNO 3.1B classification); and (b) an eye irritant (HSNO 6.4A classification). (4) In addition to the hazards referred to in subclause (3), a substance may have any of the following (but only the following) hazards: (a) acute toxicity, HSNO 6.1E classification; (b) skin irritancy, HSNO 6.3A or 6.3B classification; (c) reproductive toxicity, HSNO 6.8A, 6.8B or 6.8C classification; (d) target organ toxicity, HSNO 6.9A or 6.9B classification; (e) ecotoxicity, HSNO class 9.1B, 9.1C, 9.1D, 9.2B, 9.2C, 9.2D, 9.3B, 9.3C, 9.4B or 9.4C classification. Substances excluded from Group Standard (5) This Group Standard excludes any substance if it contains (a) asbestos; or (b) a chemical that: (i) is a persistent organic pollutant within the definition in section 2 of the Act; or (ii) exhibits the characteristics of a persistent organic pollutant as set out in paragraph 1 of Annex D to Schedule 1AA of the Act. December

4 (6) Subject to subclause (7), a substance that is available for sale in New Zealand must only be denatured with one or more of the following (a) 0.5% by volume diethyl phthalate; (b) 0.25% by volume of tertiary butyl alcohol; (c) 1% by volume acetic acid; (d) at least 1.5% and not more than 2% by volume methanol; (e) 15.6 g denatonium benzoate per 1000 litres ethyl alcohol to be denatured (15.6 ppm); (f) 10 grams of denatonium benzoate per 1000 litres of ethyl alcohol (10 ppm) together with the addition of at least 1.5% and not more than 2% by volume methanol; (g) 0.25% by volume methyl isobutyl ketone together with 5 10 g denatonium benzoate per 1000 litres ethyl alcohol to be denatured (5 10 ppm); (h) 1% by volume of petrol (unleaded); (i) 0.25% by volume tertiary butyl alcohol together with 10 g denatonium benzoate per 1000 litres ethyl alcohol to be denatured (10 ppm) (j) 2% ethyl acetate and 0.1% isopropanol. (7) Despite subclause (6), a substance that is available for sale to the general public (a) must only be denatured with the specific formulations described in subclauses 6(e), (g) and (i); and (b) should, where practicable, also contain at least 1.56 ppm methyl violet. 5. Conditions of Group Standard The conditions that specify the obligations and restrictions for substances covered by this Group Standard are set out in Schedule 1. Advisory Note: In addition to requirements specified in this document, people who are undertaking work in a workplace involving hazardous substances covered by this Group Standard have obligations under the Health and Safety at Work Act December

5 Schedule 1: Conditions of Group Standard Part 1 - Compliance with EPA Notices 1. Labelling and advertising (1) Subject to subclauses (2), substances covered by this Group Standard must comply with the relevant provisions of the Hazardous Substances (Labelling) Notice (2) Despite subclause (1) and any wording to the contrary in the Hazardous Substances (Labelling) Notice 2017, subclauses (3) to (6) apply. (3) Where a substance covered by this Group Standard is available to the general public it must carry the following statements (a) (b) (c) Read label before use ; Keep out of reach of children ; If medical advice is needed, have the product s container or label at hand. (4) A substance covered by this Group Standard must also include the following hazard and response statements (a) (b) May be harmful if swallowed ; and Call the POISONS CENTRE or doctor if you feel unwell. (5) Any substance covered by this Group Standard which contains 0.1% or more of methanol must state on the label: Contains methanol. (6) Clauses 31 and 32 of the Hazardous Substances (Labelling) Notice 2017 do not apply in relation to subclause (3) to (5), or clause 16 of the Notice. 2. Safety Data Sheets Substances covered by this Group Standard must comply with the relevant provisions of the Hazardous Substances (Safety Data Sheet) Notice Packaging (1) Subject to subclause (3), substances covered by this Group Standard must comply with the relevant provisions of the Hazardous Substances (Packaging) Notice (2) In addition to subclause (1), a substance covered by this Goup Standard when packaged in a container in quantities below 5 L must comply with clause 12 of the Hazardous Substances (Packaging) Notice (3) Despite clause 13 of the Hazardous Substances (Packaging) Notice 2017, when a substance is packaged in quantities of less than 2.5 L, that package must have clearly embossed on the shoulder or side of the container, the word POISON in capital letters, the height of the letters being not less than onefifteenth of the greatest dimension of the container. (4) Subclause (3) does not apply to a substance that is restricted to a workplace. December

6 4. Disposal Substances covered by this Group Standard must comply with the relevant provisions of the Hazardous Substances (Disposal) Notice Restrictions on supply, storage and use Substances covered by this Group Standard must comply with the relevant provisions of the Hazardous Substances (Hazardous Property Controls) Notice Part 2 - Other Matters 6. Assigning a substance to a group standard (1) If an importer or manufacturer considers that this Group Standard applies to the importation or manufacture of a substance, then the importer or manufacturer is responsible for assigning the substance to this Group Standard. (2) In order to assign the substance to this Group Standard, the importer or manufacturer must (a) ensure that the substance complies with clause 4 of this Group Standard (Scope of Group Standard); and (b) keep a record of how it was determined the substance complies with clause 4 of this Group Standard. (3) The importer or manufacturer must (a) ensure that the record contains sufficient information to allow for independent verification that the substance complies with clause 4 of this Group Standard (Scope of Group Standard); and (b) have that record available for inspection. December

7 Schedule 2: Interpretation asbestos has the same meaning as in the Health and Safety at Work (Asbestos) Regulations 2016 but does not include substances that contain naturally occurring traces of asbestos CAS number means Chemical Abstract Services Registry number condition means any obligation or restriction imposed upon a substance by a group standard denatured ethanol means a solution of more than 90% ethanol that has been denatured to render it unsuitable for human consumption, and includes methylated spirits ppm means parts per million substance means any solution of denatured ethanol that is within the scope of clause 4 of this Group Standard (Scope of Group Standard) workplace has the same meaning as in the Health and Safety at Work Act 2015 December

8 Explanatory note Denatured Ethanol Group Standard HSR This note is not part of the group standard but is intended to provide guidance to users of the group standard. (1) This Group Standard applies to all denatured ethanol products, including methylated spirits. It covers products that are available to the general public, sold only to industry and those manufactured solely for export. (2) For substances available for sale in New Zealand, the types of denaturants permitted are restricted to those set out in clause 4(6) of this Group Standard (Scope of Group Standard). Further restrictions are placed on substances available to the general public, as set out in clause 4(7). No such restrictions are placed on substances that are manufactured solely for export. (3) Under the Act, section 96E(3) provides that a hazardous substance to which section 96B(2)(a) applies is deemed to have been approved by the Authority under section 29. (4) Any transitional measures that were in this Group Standard immediately prior to 1 December 2017 but have expired have not been included in this reissued Group Standard. (5) All amendments made under section 96B to the Group Standard since it was first issued that are still in force have been incorporated into this reissued Group Standard. (6) In addition to requirements specified in this document, people who are undertaking work in a workplace involving hazardous substances covered by this Group Standard have obligations under the Health and Safety at Work Act (7) A person relying on this Group Standard will have four years (until 1 December 2021) to comply with the Labelling, Safety Data Sheet and Packaging Notices. Within that time, a person may comply with the equivalent conditions in the Group Standard in force immediately before 1 December All other aspects of this Group Standard apply from 1 December December

9 Level 10, 215 Lambton Quay, Wellington 6011, New Zealand