N.O.S. (Corrosive) Group Standard 2017 - HSR002618 GROUP STANDARD UNDER THE HAZARDOUS SUBSTANCES AND NEW ORGANISMS ACT 1996
N.O.S. (Corrosive) Group Standard 2017 N.O.S. (Corrosive) Group Standard 2017 - HSR002618 Pursuant to clause 5 of Schedule 7 of the Hazardous Substances and New Organisms Act 1996 (the Act), the Environmental Protection Authority has reviewed and, for the purpose of updating, reissues this Group Standard. Table of Contents 1. Name of Group Standard... 1 2. Commencement... 1 3. Interpretation... 1 4. Scope of Group Standard... 1 5. Conditions of Group Standard... 2 Schedule 1: Conditions of Group Standard... 3 Part 1 - Compliance with EPA Notices... 3 1. Labelling and advertising... 3 2. Safety Data Sheets... 3 3. Packaging... 3 4. Disposal... 3 5. Restrictions on supply, storage and use... 3 Part 2 - Other Matters... 3 6. Assigning a substance to a group standard... 3 7. Conditions relevant to specific use types... 4 Schedule 2: Interpretation... 5 Explanatory note... 6 December 2017
1. Name of Group Standard N.O.S. (Corrosive) Group Standard 2017 HSNO Approval Number The HSNO Approval Number for this Group Standard is HSR002618. 2. Commencement This Group Standard comes into force on 1 December 2017. 3. Interpretation (1) In this Group Standard, unless the context otherwise requires, words and phrases shall have the meanings given to them in Schedule 2. Any words or phrases that are used but not defined in this Group Standard but that are defined in the Act have the same meaning as the Act. (2) In this Group Standard, references to a hazardous property of a substance being equivalent to a specified HSNO hazard classification, means a reference to the specified hazard classification as set out in the Hazardous Substances (Classification) Notice 2017. 4. Scope of Group Standard Substances covered by Group Standard (1) This Group Standard applies to hazardous substances under section 96B(2) (b) and (c) of the Act. (2) A substance covered by this Group Standard must be a skin corrosive (HSNO 8.2B or 8.2C classification). (3) In addition to the hazard referred to in subclause (2), a substance may have any of the following (but only the following) hazards: (a) acute toxicity, HSNO 6.1D or 6.1E classification; (b) HSNO 6.1E (aspiration hazard) classification; (c) metallic corrosivity, HSNO 8.1A classification; (d) eye corrosivity, HSNO 8.3A classification; (e) eye irritancy, HSNO 6.4A classification; (f) respiratory sensitisation, HSNO 6.5A classification; (g) contact sensitisation, HSNO 6.5B classification; (h) mutagenicity, HSNO 6.6A or 6.6B classification; (i) reproductive toxicity, HSNO 6.8A, 6.8B or 6.8C classification; (j) target organ toxicity, HSNO 6.9A or 6.9B classification; (k) ecotoxicity, HSNO class 9. Substances excluded from Group Standard (4) This Group Standard excludes any substance if it contains (a) asbestos; or (b) a chemical that: (i) is a persistent organic pollutant within the definition in section 2 of the Act; or December 2017 1
(ii) exhibits the characteristics of a persistent organic pollutant as set out in paragraph 1 of Annex D to Schedule 1AA of the Act. (5) This Group Standard excludes (a) any substance that (i) was not lawfully used in New Zealand immediately before 1 July 2006; or (ii) is covered by the scope of any other group standard issued by the Authority; and (b) any fuel; and (c) pesticide actives and formulated pesticide products; and (d) veterinary medicine actives and formulated veterinary medicine products; and (e) fertilisers; and (f) cosmetic products; and (g) aerosols; and (h) gas under pressure. 5. Conditions of Group Standard The conditions that specify the obligations and restrictions for substances covered by this Group Standard are set out in Schedule 1. Advisory Note: In addition to requirements specified in this document, people who are undertaking work in a workplace involving hazardous substances covered by this Group Standard have obligations under the Health and Safety at Work Act 2015. December 2017 2
Schedule 1: Conditions of Group Standard Part 1 - Compliance with EPA Notices 1. Labelling and advertising provisions of the Hazardous Substances (Labelling) Notice 2017. 2. Safety Data Sheets provisions of the Hazardous Substances (Safety Data Sheet) Notice 2017. 3. Packaging provisions of the Hazardous Substances (Packaging) Notice 2017. 4. Disposal provisions of the Hazardous Substances (Disposal) Notice 2017. 5. Restrictions on supply, storage and use provisions of the Hazardous Substances (Hazardous Property Controls) Notice 2017. Part 2 - Other Matters 6. Assigning a substance to a group standard (1) If an importer or manufacturer considers that this Group Standard applies to the importation or manufacture of a substance, then the importer or manufacturer is responsible for assigning the substance to this Group Standard. (2) In order to assign the substance to this Group Standard, the importer or manufacturer must (a) ensure that the substance complies with clause 4 of this Group Standard (Scope of Group Standard); and (b) keep a record of how it was determined the substance complies with clause 4 of this Group Standard. (3) The importer or manufacturer must (a) ensure that the record contains sufficient information to allow for independent verification that the substance complies with clause 4 of this Group Standard (Scope of Group Standard); and (b) have that record available for inspection. December 2017 3
7. Conditions relevant to specific use types In the case of a substance that is a solvent, when that substance is collected, transported and stored for the purposes of recycling or re-use, and when it is being recycled or re-used, that substance must be managed under the relevant conditions of this Group Standard. December 2017 4
Schedule 2: Interpretation aerosol has the same meaning as in regulation 15.1 of the Health and Safety at Work (Hazardous Substances) Regulations 2017 asbestos has the same meaning as in the Health and Safety at Work (Asbestos) Regulations 2016 but does not include substances that contain naturally occurring traces of asbestos CAS number means Chemical Abstract Services Registry number gas under pressure has the same meaning as in regulation 3 of the Health and Safety at Work (Hazardous Substances) Regulations 2017 condition means any obligation or restriction imposed upon a substance by a group standard cosmetic product means any product or preparation intended to be placed in contact with the various external parts of the human body (epidermis, hair system, nails, lips and external genital organs) or with the teeth and the mucous membranes of the oral cavity with a view exclusively or mainly to cleaning them, perfuming them, changing their appearance and/or correcting body odours and/or protecting them or keeping them in good condition fertiliser means (a) any material (whether in solid or liquid form) which is described as or held out to be for or suitable for sustaining or increasing the growth, productivity or quality of plants or animals through the application of the following essential nutrients to plants or soils: nitrogen, phosphorus, potassium, sulphur, magnesium, calcium, chlorine, sodium, as major nutrients or manganese, iron, zinc, copper, boron, cobalt, molybdenum, iodine, selenium, as minor nutrients or additives; and (b) any other product which is considered to meet identified soil or plant nutrient deficiencies and is applied with this as the principal objective; and (c) the material shall be free from pathogens or any other agents which could effect disease and pest transmission N.O.S. means not otherwise specified pesticide includes but is not limited to, a product intended for use as an acaricide, antifouling paint, antisapstain, avicide, fumigant, fungicide, insecticide, herbicide, miticide, molluscicide, piscicide, timber treatment preservative or vertebrate toxic agent solvent means a liquid that dissolves a liquid, solid or gas into solution substance means any substance that is within the scope of clause 4 of this Group Standard (Scope of Group Standard) veterinary medicine has the same meaning as in the Agricultural Compounds and Veterinary Medicines Act 1997 workplace has the same meaning as in the Health and Safety at Work Act 2015 December 2017 5
Explanatory note N.O.S. (Corrosive) Group Standard 2017 - HSR002618 This note is not part of the group standard but is intended to provide guidance to users of the group standard. (1) Under the Act, section 96E(3) provides that a hazardous substance to which section 96B(2)(a) applies is deemed to have been approved by the Authority under section 29. (2) Any transitional measures that were in this Group Standard immediately prior to 1 December 2017 but have expired have not been included in this reissued Group Standard. (3) All amendments made under section 96B to the group standard since it was first issued that are still in force have been incorporated into this reissued Group Standard. (4) In addition to requirements specified in this document, people who are undertaking work in a workplace involving hazardous substances covered by this Group Standard have obligations under the Health and Safety at Work Act 2015. (5) A person relying on this Group Standard will have four years (until 1 December 2021) to comply with the Labelling, Safety Data Sheet and Packaging Notices. Within that time, a person may comply with the equivalent conditions in the Group Standard in force immediately before 1 December 2017. All other aspects of this Group Standard apply from 1 December 2017. December 2017 6
Level 10, 215 Lambton Quay, Wellington 6011, New Zealand