Page Number: 1 of 5 SECTION I - PRODUCT AND COMPANY INFORMATION Product Name: Hazard Rating: ENVIRO PRIME Health: 2 Fire: 3 Reactivity: 0 PPI: B Company Identification: Ceramic Industrial Coatings 325 Highway 81 Osseo MN 55369 Contact: SUE THILLMAN Telephone/Fax: 763-424-2044 763-424-1014 Chemtrec (24 Hour): 1-800-424-9300 Product Class Trade Name Product Code Shipping Name LACQUER IB-7810 PAINT, 3, UN 1263, PG II SECTION II - INGREDIENT AND HAZARD INFORMATION Ingredient Name CAS Number Percent TSCA NORMAL BUTYL ACETATE 123-86-4 10-30 Y ETHYL ALCOHOL 64-17-5 10-30 Y HMIS Health: Fire:3 Reactivity: PPI: CELLULOSE NITRATE 9004-70-0 1-5 N ISOPROPYL ALCOHOL 67-63-0 1-5 ETHYL ACETATE 141-78-6 1-5 Y HMIS Health: 2 Fire:3 Reactivity:0 PPI:X XYLENES 1330-20-7 < 0.5 BUTANOL 71-36-3 < 0.5 Y
Page Number: 2 of 5 1,2,4-TRIMETHYLBENZENE 000095-63-6 < 0.5 N CUMENE 98-82-8 < 0.5 N SECTION III - PHYSICAL DATA Form: LIQUID Appearance/Color: WHITE ph Value: 0. Boiling Range: 120.øF - 343.øF Evaporation Rate: Faster than n-butyl Acetate Vapor Density: Heavier than air % Volatile Weight CALCULATED 40.% % Volatile / Volume CALCULATED 64.72% Specific Gravity: 1.39901 VOC 4.31 #/GAL SECTION IV - FIRE AND EXPLOSION HAZARD DATA Flammability Class IB Flash Range: 24.øF - 120.øF Setaflash EXTINGUISHING MEDIA: Foam, CO2, Dry Chemical SPECIAL FIREFIGHTING PROCEDURES: A straight water stream would spread fires. UNUSUAL FIRE & EXPLOSION HAZARDS: Forms combustible mixture with air. SECTION V - HEALTH HAZARD DATA PERMISSIBLE EXPOSURE LEVEL: Undetermined. EFFECTS OF OVEREXPOSURE: EYES: Can cause severe irritation, redness, tearing, blurred vision. SKIN: Prolonged or repeated contact can cause moderate irritation, defatting, dermatitis. BREATHING: Excessive inhalation of vapors can cause nasal irritation,
Page Number: 3 of 5 dizziness, weakness, fatigue, nausea, headache, possible unconsciousness, and even asphyxiation. SWALLOWING: Can cause gastrointestinal irritation, nausea, vomitting diarrhea, blindness and death. Aspiration of material into the lungs can cause chemical pneumonitis which can be fatal. FIRST AID: INGESTION: Contact a physician immediately. EYE CONTACT: Immediately wash with water. CANCER INFORMATION: Ethylbenzene has been shown to cause cancer in laboratory animals. The relevance of this finding to humans is uncertain. The International Agency for Research on Cancer (IARC) has classified ehtylbenzene as a possible human carcinogen. SECTION VI - STABILITY AND REACTIVITY Stability: This product is stable Hazardous Polymerization: Hazardous polymerization will not occur INCOMPATABILITY: (Materials to avoid) Oxidizing material. CONDITIONS TO AVOID: Excessive heat and poor ventilation. HAZARDOUS DECOMPOSITION PRODUCTS: Carbon Monoxide. (If insufficient air.) SECTION VII - SPILL OR LEAK PROCEDURES STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED Use non-sparking tools and absorbent material to wipe up spill. Allow waste to dry in open pail or drum, Then fit with tight cover. WASTE DISPOSAL METHOD: Dispose of in accordance with Federal, State and Local regulations. SECTION VIII - EXPOSURE CONTROLS/PERSONAL PROTECTION Occupational Exposure Limits ACGIH TLV ACGIH TLV-C ACGIH STEL OSHA STEL OSHA PEL NORMAL BUTYL ACETATE 150.00 PPM N/est 200.00 PPM 200.00 PPM 150.00 PPM
Page Number: 4 of 5 ETHYL ALCOHOL 1000.00 PPM N/est N/est N/est 1000.00 PPM CELLULOSE NITRATE N/est N/est N/est N/est N/est ISOPROPYL ALCOHOL 400.00 PPM N/est N/est 500.00 PPM 400.00 PPM ETHYL ACETATE 400.00 PPM N/est N/est N/est 400.00 PPM XYLENES BUTANOL 100.00 PPM N/est 150.00 PPM 150.00 PPM 100.00 PPM 152.00 mg/m3 50.00 PPM N/est N/est 100.00 PPM 1,2,4-TRIMETHYLBENZENE 25.00 PPM 25.00 PPM N/est N/est 25.00 PPM CUMENE 50.00 PPM 50.00 PPM N/est N/est 50.00 PPM RESPIRATORY PROTECTION: Use approved respiratory equipment if vapor exceeds TLV. Organic vapor masks are available. PROTECTIVE GLOVES: Not required unless direct contact. EYE PROTECTION: Wear safety glasses or goggles to guard against splashes. OTHER PROTECTIVE EQUIPMENT: As required to avoid wetting clothes. SECTION IX - SPECIAL PRECAUTIONS PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Keep in a cool, dry place. OTHER PRECAUTIONS:
Page Number: 5 of 5 Ground all containers when transferring liquid. Use non-sparking tools. DISCLAIMER: The data contained herein is believed to be correct. However, since conditions of use are outside our control it should not be taken as a warranty or representation for which Ceramic Industrial Coatings assumes legal responsibility. This information is provided solely for your consideration, investigation, and verification. Seller's liability for it's products shall be limited to the return of the amount of the purchase price paid by the purchaser. Under no circumstances shall seller be liable for special, indirect or consequential damages. SECTION X - REGULATORY INFORMATION SARA TITLE III SECTION 313: This product contains the following toxic chemicals subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right to Know Act of 1986 and of 40 CFR 372: Ingredient Name CAS Number Percent XYLENES 1330-20-7 0.34 BUTANOL 71-36-3 0.22 1,2,4-TRIMETHYLBENZENE 000095-63-6 0.20 CUMENE 98-82-8 0.01 Last Page