Material Safety Data Sheet Revision Date: 03/05/2007 Issue date: 03/05/2007 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product name: 368 CHIPBONDER 10ML EFD 190151 Item No. : 17717 / IDH No. 229580 Product type: One-Part Epoxy Region: United States Company address: Henkel Corporation 15051 East Don Julian Road Industry, California 91746 Contact Information: Telephone: 626.968.6511 Emergency Telephone: 860.571.5100 Internet: www.electronics.henkel.us 2. COMPOSITION/INFORMATION ON INGREDIENTS Hazardous components % ACGIH TLV OSHA PEL OTHER 30-60 10-30 10-30 5-10 10mg/m³ Inhalable fraction, 3mg/m³ Respirable fraction, TWA 1-5 1 ppm TWA (skin) 5mg/m³ Respirable dust, 15mg/m³ Total dust 1-5 0.1-1 10 mg/m 3 TWA 15 mg/m³ TWA total dust 3. HAZARDS IDENTIFICATION EMERGENCY OVERVIEW HMIS: Physical state: Paste HEALTH: 2* Color: Orange Red FLAMMABILITY: 1 Odor: Amine PHYSICAL HAZARD: 1 Personal Protection: See Section 8 WARNING: MAY CAUSE ALLERGIC SKIN REACTION. MAY BE HARMFUL IF SWALLOWED. MAY CAUSE EYE, SKIN AND RESPIRATORY TRACT IRRITATION. Relevant routes of exposure: Skin, Inhalation, Eyes, Ingestion Potential Health Effects Inhalation: Skin contact: Eye contact: Ingestion: Mild respiratory tract irritation. Coughing. Sneezing. Fumes may be irritating or cause sensitization to the respiratory system. Allergic skin reaction. May cause moderate skin irritation. Repeated or prolonged contact can result in drying of skin. May cause severe eye irritation. May be harmful if swallowed. 1 of 5
Existing conditions aggravated by exposure: Skin disorders. Pre-existing skin, eye and respiratory allergies. Eczema. Dermatitis. See Section 11 for additional toxicological information. 4. FIRST AID MEASURES Inhalation: Skin contact: Remove to fresh air. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. If symptoms develop and persist, get medical attention. Remove contaminated clothing and shoes. Immediately flush skin with plenty of water (using soap, if available). Get medical attention if symptoms develop and persist. Wash clothing before reuse. Thoroughly clean shoes before reuse. Eye contact: Check for and remove any contact lenses. Immediately flush eyes with plenty of water for at least 15 minutes. Get medical attention. Ingestion: DO NOT induce vomiting unless directed to do so by medical personnel. Give a conscious person several glasses of water. Never give anything by mouth to an unconscious person. Get medical attention if symptoms develop and persist. 5. FIRE-FIGHTING MEASURES Flash point: Greater than 93ºC (200ºF) Tagliabue closed cup Autoignition temperature: Flammable/Explosive limits-lower %: Flammable/Explosive limits-upper %: Extinguishing media: Special fire fighting procedures: Unusual fire or explosion hazards: Hazardous combustion products: Water spray (fog), foam, dry chemical or carbon dioxide. Wear self-contained breathing apparatus and full protective clothing, such as turn-out gear. Use water spray to keep fire exposed containers cool. Oxides of carbon. Oxides of nitrogen. Oxides of sulfur. Aldehydes. Acids. Hydrocarbons. 6. ACCIDENTAL RELEASE MEASURES Environmental precautions: Clean-up methods: Prevent product from entering drains or open waters. Ensure adequate ventilation. Wear suitable protective clothing, gloves and eye/face protection. Scrape up spilled material and place in sealed container for disposal. Flush area with water to remove trace residue. 7. HANDLING AND STORAGE Handling: Storage: Use only with adequate ventilation. Avoid contact with eyes, skin and clothing. Do not taste or swallow. Do not breathe mist or vapors. Keep container closed. Wash thoroughly after handling. Keep in a cool, well ventilated area away from heat, sparks and open flame. Keep container tightly closed until ready for use. Incompatible products: Refer to Section 10. For information on product shelf life contact Henkel Customer Service at (626) 968-6511 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Engineering controls: Local exhaust ventilation is recommended when general ventilation is not sufficient to control airborne contamination below occupational exposure limits. 2 of 5
Respiratory protection: Skin protection: Eye/face protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Use impermeable gloves and protective clothing as necessary to prevent skin contact. Wear appropriate goggles, face shields or other PPE which will be effective under the circumstances if the possibility of contact exists. See Section 2 for exposure limits. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Paste Color: Orange Red Odor: Amine Vapor pressure: Less than 5 mm Hg at 20ºC (68ºF) ph: Boiling point/range: Melting point/range: Specific gravity: 1.2 Vapor density: Evaporation rate: Solubility in water: Slight Partition coefficient (n-octanol/water): Not available VOC content: Not available 10. STABILITY AND REACTIVITY Stability: Hazardous polymerization: Hazardous decomposition products: Incompatability: Conditions to avoid: Stable at normal conditions under normal processing. Oxides of carbon. Oxides of nitrogen. Oxides of sulfur. Aldehydes. Acids. Hydrocarbons. Acids. Bases. Oxidizing agents. Amines. Mercaptans. Water. Storage with incompatible materials. Heat, flames, sparks and other sources of ignition. Direct sunlight. Moisture. Avoid contact with acids and oxidizing agents. 11. TOXICOLOGICAL INFORMATION Carcinogen Status Hazardous components NTP Carcinogen IARC Carcinogen OSHA Carcinogen No Group 2B Yes Literature Referenced Target Organ & Other Health Effects 3 of 5
Hazardous components Health Effects/Target Organs Allergen, Irritant No data Allergen, Irritant Irritant Allergen, Eyes, Irritant No data Irritant, Respiratory 12. ECOLOGICAL INFORMATION Ecological information: Not available 13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: EPA hazardous waste number: Dispose of according to Federal, State and local governmental regulations. Not a RCRA hazardous waste. 14. TRANSPORT INFORMATION U.S. Department of Transportation Ground (49 CFR): Hazard class or division: International Air Transportation (ICAO/IATA): Hazard class or division: WaterTransportation (IMO/IMDG): Hazard class or division: 4 of 5
15. REGULATORY INFORMATION United States Regulatory Information TSCA 8 (b) Inventory Status: TSCA 12 (b) Export Notification: CERCLA/SARA Section 302 EHS: CERCLA/SARA Section 311/312: CERCLA/SARA 313: California Proposition 65: All components are listed or are exempt from listing on the Toxic Substances Control Act Inventory.. above reporting de minimus. Immediate Health Hazard, Delayed Health Hazard above reporting de minimus. This product contains a chemical known to the State of California to cause cancer. Canada Regulatory Information CEPA DSL/NDSL Status: WHMIS hazard class: All components are listed on or are exempt from listing on the Domestic Substances List. D.2.A, D.2.B 16. OTHER INFORMATION This material safety data sheet contains changes from the previous version in sections: New Material Safety Data Sheet format. Prepared by: Melissa Frisby, Product Safety and Regulatory Affairs Specialist For Safety and Regulatory Information contact: Product Safety and Regulatory Affairs, Rocky Hill, CT. 860-571-5204 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable. However, Henkel Corporation does not assume responsibility for any results obtained by persons over whose methods Henkel Corporation has no control. It is the user's responsibility to determine the suitability of Henkel's products or any production methods mentioned herein for a particular purpose, and to adopt such precautions as may be advisable for the protection of property and persons against any hazards that may be involved in the handling and use of any of Henkel Corporation's products. In light of the foregoing, Henkel Corporation specifically disclaims all warranties, express or implied, including warranties of merchantability and fitness for a particular purpose, arising from sale or use of Henkel Corporation's products. Henkel Corporation further disclaims any liability for consequential or incidental damages of any kind, including lost profits. 5 of 5