: EDTA, Disodium, Dihydrate

Transcription

1 SECTION 1: Identification 1.1. Identification Product form Substance name EDTA, Disodium, Dihydrate Date of issue: 10/29/2004 Revision date: 03/23/2017 Supersedes: 09/05/2013 Version: 1.1 : Substance CAS No : Product code Formula Synonyms : EDTA, Disodium, Dihydrate : LC13750 : C10H14N2O8Na2 2H2O : Ethylenediaminetetraacetic acid, disodium salt, dihydrate 1.2. Relevant identified uses of the substance or mixture and uses advised against Use of the substance/mixture Recommended use Restrictions on use 1.3. Details of the supplier of the safety data sheet : For laboratory and manufacturing use only. : Laboratory chemicals : Not for food, drug or household use LabChem Inc Jackson's Pointe Commerce Park Building 1000, 1010 Jackson's Pointe Court Zelienople, PA USA T F info@labchem.com Emergency telephone number Emergency number : CHEMTREC: or SECTION 2: Hazard(s) identification 2.1. Classification of the substance or mixture GHS-US classification Acute toxicity (oral) Category 4 Skin corrosion/irritation Category 2 Serious eye damage/eye irritation Category 2A Specific target organ toxicity (single exposure) Category 3 Full text of H statements : see section 16 H302 H315 H319 H Label elements GHS-US labeling Hazard pictograms (GHS-US) : Signal word (GHS-US) Hazard statements (GHS-US) Precautionary statements (GHS-US) GHS07 : Warning : H302 - Harmful if swallowed H315 - Causes skin irritation H319 - Causes serious eye irritation H335 - May cause respiratory irritation : P261 - Avoid breathing dust P264 - Wash exposed skin thoroughly after handling P270 - Do not eat, drink or smoke when using this product P271 - Use only outdoors or in a well-ventilated area P280 - Wear eye protection, protective gloves P301+P330+P331 - IF SWALLOWED: rinse mouth. Do NOT induce vomiting P302+P352 - IF ON SKIN: Wash with plenty of soap and water P311 - Call a POISON CENTER or doctor/physician P305+P351+P338 - If in eyes: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing P332+P313 - If skin irritation occurs: Get medical advice/attention P337+P313 - If eye irritation persists: Get medical advice/attention P362 - Take off contaminated clothing and wash it before reuse P403+P233 - Store in a well-ventilated place. Keep container tightly closed 03/23/2017 EN (English US) Page 1

2 2.3. Other hazards Other hazards not contributing to the classification 2.4. Unknown acute toxicity (GHS US) Not applicable P405 - Store locked up P501 - Dispose of contents/container to comply with local, state and federal regulations If inhaled: Remove person to fresh air and keep comfortable for breathing : None. SECTION 3: Composition/Information on ingredients 3.1. Substances Substance type : Mono-constituent Name Product identifier % GHS-US classification EDTA, Disodium, Dihydrate (Main constituent) (CAS No) Acute Tox. 4 (Oral), H302 Skin Irrit. 2, H315 Eye Irrit. 2A, H319 STOT SE 3, H335 Full text of hazard classes and H-statements : see section Mixtures Not applicable SECTION 4: First aid measures 4.1. Description of first aid measures First-aid measures general : Never give anything by mouth to an unconscious person. If you feel unwell, seek medical advice (show the label where possible). First-aid measures after inhalation : Remove victim to fresh air and keep at rest in a position comfortable for breathing. Call a POISON CENTER or doctor/physician if you feel unwell. First-aid measures after skin contact : Wash with plenty of soap and water. Wash contaminated clothing before reuse. If skin irritation occurs: Get medical advice/attention. First-aid measures after eye contact : Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. If eye irritation persists: Get medical advice/attention. First-aid measures after ingestion : Rinse mouth. Do NOT induce vomiting. Obtain emergency medical attention. Call a POISON CENTER or doctor/physician if you feel unwell Most important symptoms and effects, both acute and delayed Symptoms/injuries after inhalation : May cause respiratory irritation. Symptoms/injuries after skin contact : Causes skin irritation. Symptoms/injuries after eye contact : Causes serious eye irritation. Symptoms/injuries after ingestion : Swallowing a small quantity of this material will result in serious health hazard Indication of any immediate medical attention and special treatment needed SECTION 5: Firefighting measures 5.1. Extinguishing media Suitable extinguishing media Unsuitable extinguishing media 5.2. Special hazards arising from the substance or mixture : Foam. Dry powder. Carbon dioxide. Water spray. Sand. : Do not use a heavy water stream Advice for firefighters Firefighting instructions Protection during firefighting : Use water spray or fog for cooling exposed containers. Exercise caution when fighting any chemical fire. Prevent fire-fighting water from entering environment. : Do not enter fire area without proper protective equipment, including respiratory protection. SECTION 6: Accidental release measures 6.1. Personal precautions, protective equipment and emergency procedures For non-emergency personnel Protective equipment : Gloves. Safety glasses. 03/23/2017 EN (English US) 2/6

3 Emergency procedures For emergency responders Protective equipment Emergency procedures : Evacuate unnecessary personnel. : Equip cleanup crew with proper protection. : Ventilate area Environmental precautions Prevent entry to sewers and public waters. Notify authorities if liquid enters sewers or public waters Methods and material for containment and cleaning up Methods for cleaning up 6.4. Reference to other sections See Heading 8. Exposure controls and personal protection. SECTION 7: Handling and storage 7.1. Precautions for safe handling Precautions for safe handling Hygiene measures 7.2. Conditions for safe storage, including any incompatibilities Storage conditions Incompatible products Incompatible materials : On land, sweep or shovel into suitable containers. Minimize generation of dust. Store away from other materials. : Wash hands and other exposed areas with mild soap and water before eating, drinking or smoking and when leaving work. Provide good ventilation in process area to prevent formation of vapor. Avoid breathing dust. Use only outdoors or in a well-ventilated area. : Do not eat, drink or smoke when using this product. Wash exposed skin thoroughly after handling. : Keep container tightly closed. : Strong oxidizers. SECTION 8: Exposure controls/personal protection 8.1. Control parameters : Sources of ignition. Generation of airborne dust Exposure controls Appropriate engineering controls Personal protective equipment : Emergency eye wash fountains and safety showers should be available in the immediate vicinity of any potential exposure. Ensure adequate ventilation. : Safety glasses. Gloves. Dust/aerosol mask. Hand protection Eye protection Respiratory protection Other information : Wear protective gloves. : Chemical goggles or safety glasses. : Dust formation: dust mask. : Do not eat, drink or smoke during use. SECTION 9: Physical and chemical properties 9.1. Information on basic physical and chemical properties Physical state : Solid Appearance : Powder. Color : white Odor : Odorless Odor threshold ph : 4-6 5% solution at 25 C Melting point : 252 C Freezing point Boiling point 03/23/2017 EN (English US) 3/6

4 Flash point Relative evaporation rate (butyl acetate=1) Flammability (solid, gas) Vapor pressure Relative vapor density at 20 C Relative density Molecular mass Solubility Log Pow Auto-ignition temperature Decomposition temperature Viscosity, kinematic Viscosity, dynamic Explosion limits Explosive properties Oxidizing properties : Non flammable. : g/mol : Soluble in water. Water: 11 g/100ml : Not applicable. : None Other information SECTION 10: Stability and reactivity Reactivity Chemical stability Stable under normal conditions Possibility of hazardous reactions Not established Conditions to avoid Extremely high or low temperatures Incompatible materials Strong oxidizers Hazardous decomposition products Nitrogen oxides. Carbon monoxide. Carbon dioxide. SECTION 11: Toxicological information Information on toxicological effects Likely routes of exposure Acute toxicity LD50 oral rat ATE US (oral) Skin corrosion/irritation Serious eye damage/irritation Respiratory or skin sensitization Germ cell mutagenicity Carcinogenicity Reproductive toxicity Specific target organ toxicity single exposure : Inhalation; Skin and eye contact : Oral: Harmful if swallowed mg/kg mg/kg body weight : Causes skin irritation. ph: 4-6 5% solution at 25 C : Causes serious eye irritation. ph: 4-6 5% solution at 25 C : May cause respiratory irritation. 03/23/2017 EN (English US) 4/6

5 Specific target organ toxicity repeated exposure Aspiration hazard Potential Adverse human health effects and symptoms Symptoms/injuries after inhalation Symptoms/injuries after skin contact Symptoms/injuries after eye contact Symptoms/injuries after ingestion : Based on available data, the classification criteria are not met. Harmful if swallowed. : May cause respiratory irritation. : Causes skin irritation. : Causes serious eye irritation. : Swallowing a small quantity of this material will result in serious health hazard. SECTION 12: Ecological information Toxicity LC50 fish 1 >= 500 mg/l Persistence and degradability Persistence and degradability Not established Bioaccumulative potential Bioaccumulative potential Not established Mobility in soil Other adverse effects Other information : Avoid release to the environment. SECTION 13: Disposal considerations Waste treatment methods Waste disposal recommendations : Dispose in a safe manner in accordance with local/national regulations. Ecology - waste materials : Avoid release to the environment. SECTION 14: Transport information Department of Transportation (DOT) In accordance with DOT Not regulated SECTION 15: Regulatory information US Federal regulations Listed on the United States TSCA (Toxic Substances Control Act) inventory All components of this product are listed, or excluded from listing, on the United States Environmental Protection Agency Toxic Substances Control Act (TSCA) inventory This product or mixture does not contain a toxic chemical or chemicals in excess of the applicable de minimis concentration as specified in 40 CFR (a) subject to the reporting requirements of section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 and 40 CFR Part /23/2017 EN (English US) 5/6

6 15.2. International regulations CANADA Listed on the Canadian DSL (Domestic Substances List) WHMIS Classification Class D Division 2 Subdivision B - Toxic material causing other toxic effects EU-Regulations National regulations Not listed on the Canadian IDL (Ingredient Disclosure List) US State regulations California Proposition 65 - This product does not contain any substances known to the state of California to cause cancer, developmental and/or reproductive harm SECTION 16: Other information Revision date : 03/23/2017 Other information : None. Full text of H-phrases: see section 16: H302 Harmful if swallowed H315 Causes skin irritation H319 Causes serious eye irritation H335 May cause respiratory irritation NFPA health hazard NFPA fire hazard NFPA reactivity : 1 - Materials that, under emergency conditions, can cause significant irritation. : 0 - Materials that will not burn under typical dire conditions, including intrinsically noncombustible materials such as concrete, stone, and sand. : 0 - Material that in themselves are normally stable, even under fire conditions. HMIS III Rating Health Flammability Physical Personal protection : 1 Slight Hazard - Irritation or minor reversible injury possible : 0 Minimal Hazard - Materials that will not burn : 0 Minimal Hazard - Materials that are normally stable, even under fire conditions, and will NOT react with water, polymerize, decompose, condense, or self-react. Non-Explosives. : E E - Safety glasses, Gloves, Dust respirator SDS US LabChem Information in this SDS is from available published sources and is believed to be accurate. No warranty, express or implied, is made and LabChem Inc assumes no liability resulting from the use of this SDS. The user must determine suitability of this information for his application. 03/23/2017 EN (English US) 6/6