SAFETY DATA SHEET. 1. Identification. 2. Hazard(s) identification

Transcription

1 SAFETY DATA SHEET 1. Identification Product identifier Other means of identification SDS number Part. Tariff code Recommended use Recommended restrictions Tite Seal Medium Weight Gasket & Joint Compound T2566 T2566, T Gasket & Joint Compound ne known. Manufacturer/Importer/Supplier/Distributor information Manufacturer Company name RSC Chemical Solutions Address 600 Radiator Road Indian Trail, NC Telephone United States Customer Service: (704) Technical: (704) Website Emergency phone number Emergency Telephone: (303) Emergency Contact: RMPDC ( ) 2. Hazard(s) identification Physical hazards Health hazards Environmental hazards OSHA defined hazards Label elements t classified. Sensitization, respiratory Sensitization, skin t classified. t classified. Category 1 Category 1 Signal word Hazard statement Precautionary statement Prevention Response Storage Disposal Hazard(s) not otherwise classified (HNOC) Supplemental information Danger May cause an allergic skin reaction. May cause allergy or asthma symptoms or breathing difficulties if inhaled. Avoid breathing dust/fume/gas/mist/vapors/spray. Contaminated work clothing must not be allowed out of the workplace. Wear protective gloves. In case of inadequate ventilation wear respiratory protection. If on skin: Wash with plenty of water. If inhaled: If breathing is difficult, remove person to fresh air and keep comfortable for breathing. If skin irritation or rash occurs: Get medical advice/attention. If experiencing respiratory symptoms: Call a poison center/doctor. Wash contaminated clothing before reuse. Store away from incompatible materials. Dispose of contents/container in accordance with local/regional/national/international regulations. ne known. ne. 1 / 8

2 3. Composition/information on ingredients Mixtures Chemical name Common name and synonyms CAS number % Aluminium Oxide < 20 Aluminum And Potassium Silicate (mica) < 20 Kaolin < 20 Gum Rosin < 3 Other components below reportable levels 50 - < 60 *Designates that a specific chemical identity and/or percentage of composition has been withheld as a trade secret. 4. First-aid measures Inhalation Skin contact Eye contact Ingestion Most important symptoms/effects, acute and delayed Indication of immediate medical attention and special treatment needed General information 5. Fire-fighting measures Suitable extinguishing media Unsuitable extinguishing media Specific hazards arising from the chemical Special protective equipment and precautions for firefighters Fire fighting equipment/instructions Specific methods General fire hazards If breathing is difficult, remove to fresh air and keep at rest in a position comfortable for breathing. Oxygen or artificial respiration if needed. Do not use mouth-to-mouth method if victim inhaled the substance. Induce artificial respiration with the aid of a pocket mask equipped with a one-way valve or other proper respiratory medical device. If experiencing respiratory symptoms: Call a POISON CENTER or doctor/physician. Remove contaminated clothing immediately and wash skin with soap and water. In case of eczema or other skin disorders: Seek medical attention and take along these instructions. Rinse with water. Get medical attention if irritation develops and persists. Rinse mouth. Get medical attention if symptoms occur. Difficulty in breathing. May cause an allergic skin reaction. Dermatitis. Rash. Provide general supportive measures and treat symptomatically. Keep victim under observation. Symptoms may be delayed. Ensure that medical personnel are aware of the material(s) involved, and take precautions to protect themselves. Wash contaminated clothing before reuse. Water fog. Foam. Dry chemical powder. Carbon dioxide (CO2). Do not use water jet as an extinguisher, as this will spread the fire. During fire, gases hazardous to health may be formed. Self-contained breathing apparatus and full protective clothing must be worn in case of fire. Move containers from fire area if you can do so without risk. Use standard firefighting procedures and consider the hazards of other involved materials. unusual fire or explosion hazards noted. 6. Accidental release measures Personal precautions, protective equipment and emergency procedures Methods and materials for containment and cleaning up Keep unnecessary personnel away. Keep people away from and upwind of spill/leak. Wear appropriate protective equipment and clothing during clean-up. Do not touch damaged containers or spilled material unless wearing appropriate protective clothing. Ensure adequate ventilation. Local authorities should be advised if significant spillages cannot be contained. For personal protection, see section 8 of the SDS. Stop the flow of material, if this is without risk. Dike far ahead of spill for later disposal. Following product recovery, flush area with water. Environmental precautions Never return spills to original containers for re-use. For waste disposal, see section 13 of the SDS. Avoid discharge into drains, water courses or onto the ground. 2 / 8

3 7. Handling and storage Precautions for safe handling Conditions for safe storage, including any incompatibilities Provide adequate ventilation. Avoid breathing dust/fume/gas/mist/vapors/spray. Avoid contact with eyes, skin, and clothing. Avoid prolonged exposure. Wear appropriate personal protective equipment. Observe good industrial hygiene practices. Store in original tightly closed container. Store in a well-ventilated place. Keep out of the reach of children. Store away from incompatible materials (see Section 10 of the SDS). 8. Exposure controls/personal protection Occupational exposure limits US. OSHA Table Z-1 Limits for Air Contaminants (29 CFR ) Components Type Value Form Aluminium Oxide (CAS ) US. OSHA Table Z-3 (29 CFR ) Components PEL 5 mg/m3 Respirable fraction. 15 mg/m3 Total dust. PEL 5 mg/m3 Respirable fraction. 15 mg/m3 Total dust. Type Value Aluminum And Potassium Silicate (mica) (CAS ) TWA 20 mppcf US. ACGIH Threshold Limit Values Components Type Value Form Aluminium Oxide (CAS ) Aluminum And Potassium Silicate (mica)(cas ) US. NIOSH: Pocket Guide to Chemical Hazards Components Type Aluminum And Potassium Silicate (mica)(cas ) Gum Rosin (CAS ) Biological limit values Appropriate engineering controls TWA 1 mg/m3 Respirable fraction. TWA 3 mg/m3 Respirable fraction. TWA 2 mg/m3 Respirable fraction. Value Form TWA 3 mg/m3 Respirable. TWA 0.1 mg/m3 TWA 5 mg/m3 Respirable. 10 mg/m3 Total biological exposure limits noted for the ingredient(s). Good general ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. If applicable, use process enclosures, local exhaust ventilation, or other engineering controls to maintain airborne levels below recommended exposure limits. If exposure limits have not been established, maintain airborne levels to an acceptable level. General ventilation normally adequate. Individual protection measures, such as personal protective equipment If contact is likely, safety glasses with side shields are recommended. Eye/face protection Skin protection Hand protection Other Respiratory protection Thermal hazards General hygiene considerations Wear appropriate chemical resistant gloves. Suitable gloves can be recommended by the glove supplier. Wear appropriate chemical resistant clothing. Wear positive pressure self-contained breathing apparatus (SCBA). Wear appropriate thermal protective clothing, when necessary. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking, and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. Contaminated work clothing should not be allowed out of the workplace. 3 / 8

4 9. Physical and chemical properties Appearance Odor Physical state Form Color Odor threshold ph Melting point/freezing point Initial boiling point and boiling range Flash point Evaporation rate Flammability (solid, gas) Viscous. Paste. Liquid. Dark grey Characteristic odor 3632 F (2000 C) estimated 5396 F (2980 C) estimated F (148.9 C) Cleveland Open Cup Upper/lower flammability or explosive limits Flammability limit - lower (%) Flammability limit - upper (%) Explosive limit - lower (%) Explosive limit - upper (%) Vapor pressure Vapor density Relative density Solubility(ies) Solubility (water) Partition coefficient (n-octanol/water) Auto-ignition temperature Decomposition temperature Viscosity Other information Density Explosive properties Flammability class Oxidizing properties Percent volatile Specific gravity 1.2 VOC (Weight %) hpa estimated lbs/gal t explosive. Combustible IIIB estimated t oxidizing. < 1 % w/w 0 % w/w 10. Stability and reactivity Reactivity Chemical stability Possibility of hazardous reactions Conditions to avoid Incompatible materials Hazardous decomposition products The product is stable and non-reactive under normal conditions of use, storage and transport. Material is stable under normal conditions. dangerous reaction known under conditions of normal use. Contact with incompatible materials. Acids. Chlorine. hazardous decomposition products are known. 4 / 8

5 11. Toxicological information Information on likely routes of exposure Inhalation May cause allergy or asthma symptoms or breathing difficulties if inhaled. Prolonged inhalation may be harmful. Skin contact Eye contact Ingestion Symptoms related to the physical, chemical and toxicological characteristics Information on toxicological effects Acute toxicity Components Acute May cause an allergic skin reaction. Direct contact with eyes may cause temporary irritation. Expected to be a low ingestion hazard. Difficulty in breathing. May cause an allergic skin reaction. Dermatitis. Rash. May cause an allergic skin reaction. Species Test Results Dermal LD50 Rat > 5000 mg/kg Oral LD50 Rat > 5000 mg/kg * Estimates for product may be based on additional component data not shown. Skin corrosion/irritation Serious eye damage/eye irritation Respiratory or skin sensitization ACGIH Sensitization Gum Rosin (CAS ) Prolonged skin contact may cause temporary irritation. Direct contact with eyes may cause temporary irritation. Dermal sensitization Respiratory sensitization Respiratory sensitization May cause allergy or asthma symptoms or breathing difficulties if inhaled. Skin sensitization Germ cell mutagenicity Carcinogenicity May cause an allergic skin reaction. data available to indicate product or any components present at greater than 0.1% are mutagenic or genotoxic. This product is not considered to be a carcinogen by IARC, ACGIH, NTP, or OSHA. OSHA Specifically Regulated Substances (29 CFR ) t listed. Reproductive toxicity Specific target organ toxicity - single exposure Specific target organ toxicity - repeated exposure Aspiration hazard Chronic effects 12. Ecological information Ecotoxicity Persistence and degradability Bioaccumulative potential Mobility in soil Other adverse effects This product is not expected to cause reproductive or developmental effects. t classified. t classified. t likely, due to the form of the product. Prolonged inhalation may be harmful. The product is not classified as environmentally hazardous. However, this does not exclude the possibility that large or frequent spills can have a harmful or damaging effect on the environment. data is available on the degradability of this product. data available. data available. other adverse environmental effects (e.g. ozone depletion, photochemical ozone creation potential, endocrine disruption, global warming potential) are expected from this component. 5 / 8

6 13. Disposal considerations Disposal instructions Local disposal regulations Hazardous waste code Waste from residues / unused products Contaminated packaging 14. Transport information DOT t regulated as dangerous goods. IATA t regulated as dangerous goods. IMDG t regulated as dangerous goods. Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code 15. Regulatory information US federal regulations Collect and reclaim or dispose in sealed containers at licensed waste disposal site. Dispose of contents/container in accordance with local/regional/national/international regulations. Dispose in accordance with all applicable regulations. The waste code should be assigned in discussion between the user, the producer and the waste disposal company. Dispose of in accordance with local regulations. Empty containers or liners may retain some product residues. This material and its container must be disposed of in a safe manner (see: Disposal instructions). Since emptied containers may retain product residue, follow label warnings even after container is emptied. Empty containers should be taken to an approved waste handling site for recycling or disposal. t established. t applicable. This product is a "Hazardous Chemical" as defined by the OSHA Hazard Communication Standard, 29 CFR One or more components are not listed on TSCA. TSCA Section 12(b) Export tification (40 CFR 707, Subpt. D) t regulated. CERCLA Hazardous Substance List (40 CFR 302.4) t listed. SARA 304 Emergency release notification t regulated. OSHA Specifically Regulated Substances (29 CFR ) t listed. Superfund Amendments and Reauthorization Act of 1986 (SARA) Hazard categories Immediate Hazard - Delayed Hazard - Fire Hazard - Pressure Hazard - Reactivity Hazard - SARA 302 Extremely hazardous substance t listed. SARA 311/312 Hazardous chemical SARA 313 (TRI reporting) Chemical name CAS number % by wt. Aluminium Oxide < 20 Other federal regulations Clean Air Act (CAA) Section 112 Hazardous Air Pollutants (HAPs) List t regulated. Clean Air Act (CAA) Section 112(r) Accidental Release Prevention (40 CFR ) t regulated. Safe Drinking Water Act (SDWA) t regulated. 6 / 8

7 US state regulations US. California Controlled Substances. CA Department of Justice (California Health and Safety Code Section 11100) t listed. US. Massachusetts RTK - Substance List Aluminium Oxide (CAS ) Aluminum And Potassium Silicate (mica) (CAS ) US. New Jersey Worker and Community Right-to-Know Act Aluminium Oxide (CAS ) Aluminum And Potassium Silicate (mica) (CAS ) US. Pennsylvania Worker and Community Right-to-Know Law Aluminium Oxide (CAS ) Aluminum And Potassium Silicate (mica) (CAS ) Gum Rosin (CAS ) US. Rhode Island RTK Aluminium Oxide (CAS ) US. California Proposition 65 WARNING: This product contains a chemical known to the State of California to cause cancer. US - California Proposition 65 - CRT: Listed date/carcinogenic substance Carbon Black (CAS ) Listed: February 21, 2003 Quartz [silica Crystalline] (CAS ) Listed: October 1, 1988 International Inventories Country(s) or region Inventory name On inventory (yes/no)* Australia Australian Inventory of Chemical Substances (AICS) Canada Canada China Europe Europe Japan Korea New Zealand Philippines Domestic Substances List (DSL) n-domestic Substances List (NDSL) Inventory of Existing Chemical Substances in China (IECSC) European Inventory of Existing Commercial Chemical Substances (EINECS) European List of tified Chemical Substances (ELINCS) Inventory of Existing and New Chemical Substances (ENCS) Existing Chemicals List (ECL) New Zealand Inventory Philippine Inventory of Chemicals and Chemical Substances (PICCS) United States & Puerto Rico Toxic Substances Control Act (TSCA) Inventory *A "" indicates that all components of this product comply with the inventory requirements administered by the governing country(s) A "" indicates that one or more components of the product are not listed or exempt from listing on the inventory administered by the governing country(s). 16. Other information, including date of preparation or last revision Issue date Version # 01 HMIS ratings NFPA ratings NFPA ratings Health: 2* Flammability: 0 Physical hazard: 0 Health: 2 Flammability: 0 Instability: / 8

8 Disclaimer The information provided in this Safety Data Sheet is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guidance for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other materials or in any process, unless specified in the text. 8 / 8