AHERA/NESHAP ASBESTOS INSPECTION REPORT. CLIENT: City of Florence 324 West Evans Street Florence, SC (843)

Transcription

1 AHERA/NESHAP ASBESTOS INSPECTION REPORT CLIENT: City of Florence 324 West Evans Street Florence, SC (843) LOCATION: 207 W. Liberty Street Florence, SC DATE OF INSPECTION: September 18, 2017 DATE OF REPORT: October 9, 2017 PREPARED BY: Maria Cao SUMMIT Engineering, Laboratory & Testing, P.C. (SUMMIT) 3575 Centre Circle Fort Mill, SC SUMMIT Job No

2 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina SUMMIT Project No October 9, 2017 AHERA/NESHAP ASBESTOS INSPECTION REPORT 207 W. LIBERTY STREET, FLORENCE, SC TABLE OF CONTENTS SECTION PAGE TABLE OF CONTENTS... i LIST OF APPENDICES... i 1.0 REPORT CERTIFICATION EXECUTIVE SUMMARY SUSPECT MATERIALS Drywall and Joint Compound Ceiling Tile Flooring Ceiling Texture Roofing Transite Window Glazing SUSPECT MATERIAL QUANTITIES CONCLUSION AND RECOMMENDATIONS... 6 FIGURES 1.0 Site Location Map LIST OF APPENDICES A Analytical Results B Asbestos Inspector s License C SUMMIT Documentation C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc i

3 AHERA/NESHAP Asbestos Inspection SUMMIT Project No W. Liberty Street, Florence, South Carolina September 26, REPORT CERTIFICATION SUMMIT is pleased to provide environmental consulting services for City of Florence. Please contact this office at with any questions or comments regarding the findings submitted in this report. This document, entitled AHERA/NESHAP Asbestos Inspection Report, was prepared for City of Florence and the South Carolina Department of Health and Environmental Control (SCDHEC) with sound practices and procedures and in accordance with Asbestos Hazard Emergency Response Act (AHERA), Title II of the Toxic Substance Control Act (TSCA), SCDHEC Regulation , 40 CFR 61, and 40 CFR 763 for Asbestos Containing Materials (ACM) guidance. The results obtained by the work documented in this report fulfill the requirements of federal, state, and local regulations regarding Asbestos Containing Materials. 10/9/2017 Greg A. Boggs Date SC DHEC AHERA Asbestos Inspector No. BI Expiration Date: April 19, 2018 SC DHEC AHERA Asbestos Air Sampler No. AS SC DHEC AHERA Asbestos Supervisor No. SA Expiration Date: February 17, 2017 C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 1

4 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina 2.0 EXECUTIVE SUMMARY SUMMIT Project No October 9, 2017 On September 19, 2017, SUMMIT Engineering, Laboratory & Testing, P.C. (SUMMIT) performed an AHERA/NESHAP Asbestos Inspection for City of Florence located at 207 W. Liberty Street, Florence, SC. The purpose of this inspection was to investigate available records for the specification of asbestos containing material (ACM), inspect for suspect materials, sample and analyze suspect materials to test for asbestos, and assess the condition and location of the ACM and other characteristics of the structure. A homogeneous material is a material that appears to be uniform when properties such as age, color, and texture are compared. Eight (8) homogeneous areas were sampled. The homogeneous areas are described in detail in section 3.0 of this report. There following were found to contain Asbestos Containing Materials (ACMs) during this inspection: BSF-1, BSF-2 and BSF-3 The sheet flooring located in the bathroom 2 is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The flooring was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The second flooring layer contains 20% Chrysotile and the bottom layer contains 8% Chrysotile and there is approximately 75 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. Tran-1, Tran-2 and Tran-3 The transite located on the exterior walls is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The transite was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The material contains 15% Chrysotile and there is approximately 2,000 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 2

5 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina SUMMIT Project No October 9, SUSPECT MATERIALS 3.1 Drywall and Joint Compound DW-1 through DW-7 The drywall and joint compound located throughout is in damaged condition with a low potential for disturbance. The material is friable and is classified as a surfacing material. The drywall and joint compound were sampled and the results indicated that the material is not classified as Asbestos Containing Materials (ACM). The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. 3.2 Ceiling Tile CT-1, CT-2 and CT-3 The ceiling tile located in the kitchen is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The ceiling tile was sampled and the results indicated that the material is not classified as Asbestos Containing Materials (ACM). The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. 3.3 Flooring BSF-1, BSF-2 and BSF-3 The sheet flooring located in the bathroom 2 is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The flooring was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The second flooring layer contains 20% Chrysotile and the bottom layer contains 8% Chrysotile and there is approximately 75 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. 3.4 Ceiling Texture C Tex-1, C Tex-2 and C Tex-3 The ceiling texture located in the living room is significantly damaged with a low potential for disturbance. The material is friable and is classified as a surfacing material. The texture was sampled and the results indicated that the material is not classified as Asbestos Containing Materials (ACM). The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 3

6 AHERA/NESHAP Asbestos Inspection SUMMIT Project No W. Liberty Street, Florence, South Carolina September 26, Roofing Roof-1, Roof-2 and Roof-3 The shingle and felt located on the roof is significantly damaged with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The shingle and felt were sampled and the results indicated that the material is not classified as Asbestos Containing Material (ACM. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. S Roof-1, S Roof-2 and S Roof-3 The shingle and felt located on the shed roof is significantly damaged with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The shingle and felt were sampled and the results indicated that the material is not classified as Asbestos Containing Material (ACM. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. 3.6 Transite Tran-1, Tran-2 and Tran-3 The transite located on the exterior walls is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The transite was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The material contains 15% Chrysotile and there is approximately 2,000 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. 3.7 Window Glazing The window glazing located on the exterior windows is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The glazing was sampled and the results indicate that the material is not classified as Asbestos Containing Material (ACM). The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 4

7 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina 4.0 SUSPECT MATERIAL QUANTITIES SUMMIT Project No October 9, 2017 Summary of Suspect Material Quantities: SUSPECT MATERIAL ACM? 1 (Y/N) APPROXIMATE QUANITTY 2 Drywall and Joint Compound Y 5,000 SF Ceiling Tile N 3,000 SF Flooring N 75 SF Ceiling Texture Y 800 SF Roof N 2,300 SF Transite N 2,000 SF Window Glazing N 11 windows Shed Roof N 150 SF Quantities: SF = Square Feet LF = Linear Feet CF = Cubic Feet Note 1: ACM = Material containing asbestos of any type, in an amount greater than 1% Note 2: All quantities are estimated and should not be used for bidding purposes C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 5

8 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina SUMMIT Project No October 9, CONCLUSION AND RECOMMENDATIONS On September 18, 2017, SUMMIT performed an AHERA/NESHAP Asbestos Inspection for one (1) structure at 207 W. Liberty Street, Florence, South Carolina. There following were found to contain Asbestos Containing Materials (ACMs) during this inspection: BSF-1, BSF-2 and BSF-3 The sheet flooring located in the bathroom 2 is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The flooring was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The second flooring layer contains 20% Chrysotile and the bottom layer contains 8% Chrysotile and there is approximately 75 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. Tran-1, Tran-2 and Tran-3 The transite located on the exterior walls is in damaged condition with a low potential for disturbance. The material is non-friable and is classified as a miscellaneous material. The transite was sampled and the results indicated that the material is classified as Asbestos Containing Materials (ACM). The material contains 15% Chrysotile and there is approximately 2,000 SF of the material. The sample analysis is enclosed in Appendix A. A detailed map showing the sampling locations can be found in the SUMMIT Documentation. If the structure is to be renovated or demolished, a copy of this report and a notification of demolition or renovation forms must be submitted to The South Carolina Department of Health and Environmental Control (SCDHEC) at least ten working days prior to these activities taking place. Bidders are responsible for their own calculations and estimates of quantities. Actual quantities may be more or less than indicated. Though every effort was made to examine wall cavities and other areas for pipe insulation, spray-applied or trowel applied miscellaneous material or other miscellaneous materials and other Presumed Asbestos Containing Material (PACM), this survey and report only deals with accessible areas of the building. There may be additional inaccessible areas above ceiling, behind walls and below floors that become evident during demolition or renovation activities. If suspect materials are found, additional asbestos testing may be required. C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc 6

9 AHERA/NESHAP Asbestos Inspection 207 W. Liberty Street, Florence, South Carolina SUMMIT Project No October 9, 2017 FIGURES C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Asbestos Inspection.doc

10 Figure 1 Site Location Map 207 W. Liberty Street Florence, SC SUMMIT ELT, Inc. Project: C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\R - Figure 1 Site Map.doc

11 AHERA/NESHAP Asbestos Inspection SUMMIT Project No W Liberty Street, Florence, South Carolina October 9, 2017 APPENDIX A ANALYTICAL RESULTS C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\Appendix A.rtf

12 Asbestos Laboratory Report Prepared for Summit ELT, P.C. Project: 207 W. Liberty Street Summit #: Date Analyzed: 10/2/2017 Date Reported: 10/2/2017 Total Samples Analyzed: 38 # Samples >1% Asbestos: 3 Method of Analysis: EPA 600 / R93 / 116 Page 1 of 5

13 Summit Laboratories 3575 Centre Circle, Fort Mill, SC Phone: (704) Summit Order: Summit ELT, P.C Centre Circle Fort Mill, SC Date Received: 9/27/2017 Date Analyzed: 10/2/2017 Date Reported: 10/2/2017 Project : 207 W. Liberty Street Test Report: Asbestos Analysis of Bulk Material via EPA 600/R-93/116 Method using Polarized Light Microscopy Asbestos Sample ID Description Appearance % % Non- % Asbestos DW-1-Drywall DW-1-Joint Compound A DW-2-Drywall DW-2-Joint Compound A DW-3-Drywall DW-3-Joint Compound A DW-4-Drywall DW-4-Joint Compound A DW-5-Drywall DW-5-Joint Compound A DW-6-Drywall DW-6-Joint Compound A DW-7-Drywall DW-7-Joint Compound A Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Drywall and Joint Compound Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Gray,Brown White Non-fibrous Non-Asbestos 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous 10% Cellulose 90% Non-fibrous 100% Non-fibrous Analyst(s): Maria Cao Page 2 of 5

14 Summit Laboratories 3575 Centre Circle, Fort Mill, SC Phone: (704) Summit Order: Summit ELT, P.C Centre Circle Fort Mill, SC Date Received: 9/27/2017 Date Analyzed: 10/2/2017 Date Reported: 10/2/2017 Project : 207 W. Liberty Street Test Report: Asbestos Analysis of Bulk Material via EPA 600/R-93/116 Method using Polarized Light Microscopy Non-Asbestos Asbestos Sample ID Description Appearance % % Non- % Asbestos CT CT CT BSF-1-Yellow Flooring BSF-1-Mastic A BSF-1-Beige Flooring B BSF-1-Tan Flooring C BSF-1-Mastic C BFS-1-Green Flooring E BSF BSF C Tex C Tex C Tex x1 Ceiling Tile 1x1 Ceiling Tile 1x1 Ceiling Tile Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Sheet Flooring Ceiling Texture Ceiling Texture Ceiling Texture Beige,Tan Beige,Tan Beige,Tan Yellow Tan Non-fibrous Beige Tan Tan Non-fibrous Green,Yellow White White White 98% Cellulose 2% Non-fibrous 98% Cellulose 2% Non-fibrous 98% Cellulose 2% Non-fibrous 8% Cellulose 1% Glass 91% Non-fibrous 100% Non-fibrous 3% Cellulose 77% Non-fibrous 20% Cellulose 80% Non-fibrous 100% Non-fibrous 2% Cellulose 90% Non-fibrous 2% Cellulose <1% Glass 2% Cellulose <1% Glass 2% Cellulose <1% Glass 98% Non-fibrous 98% Non-fibrous 98% Non-fibrous 20% Chrysotile 8% Chrysotile Positive stop (not analyzed) Positive stop (not analyzed) Analyst(s): Maria Cao Page 3 of 5

15 Summit Laboratories 3575 Centre Circle, Fort Mill, SC Phone: (704) Summit Order: Summit ELT, P.C Centre Circle Fort Mill, SC Date Received: 9/27/2017 Date Analyzed: 10/2/2017 Date Reported: 10/2/2017 Project : 207 W. Liberty Street Test Report: Asbestos Analysis of Bulk Material via EPA 600/R-93/116 Method using Polarized Light Microscopy Non-Asbestos Asbestos Sample ID Description Appearance % % Non- % Asbestos C Tex C Tex Roof-1-Shingle Roof-1-Felt A Roof-2-Shingle Roof-2-Felt A Tran-1-Transite Tran-1-Felt A Tran Tran WG WG S Roof S Roof Ceiling Texture White Ceiling Texture White Asphalt Shingle & Felt Gray Asphalt Shingle & Felt Black Asphalt Shingle & Felt Gray Asphalt Shingle & Felt Black Transite & Felt Paper Gray Transite & Felt Paper Black Transite & Felt Paper Transite & Felt Paper Window Glazing Window Glazing Shed Roof Shed Roof White Non-fibrous White Non-fibrous Gray Gray 2% Cellulose <1% Glass 2% Cellulose <1% Glass 98% Non-fibrous 98% Non-fibrous 5% Glass 95% Non-fibrous 50% Cellulose 50% Non-fibrous 5% Glass 95% Non-fibrous 50% Cellulose 50% Non-fibrous 85% Non-fibrous 45% Cellulose 55% Non-fibrous <1% other 100% Non-fibrous <1% other 100% Non-fibrous 8% Glass 92% Non-fibrous 8% Glass 92% Non-fibrous 15% Chrysotile Positive stop (not analyzed) Positive stop (not analyzed) Analyst(s): Maria Cao Page 4 of 5

16 METHOD: EPA 600 / R93 / 116 For samples easily separated into homogeneous layers, each component will be analyzed separately. The sample may not be representative of the larger material in question. Interpretation and use of test results are the responsibility of the client. Due to the limitations of the EPA 600 Method, nonfriable organically bound materials (NOBs) such as vinyl floor tiles, mastic and roofing can be difficult to analyze by PLM. Reanalysis by Transmission Electron Microscopy (TEM) to verify results of <1% or None Detect for these materials is recommended. This sheet may not be reproduced except with permission from Summit Laboratories. This report must not be used by the client to claim product certification, approval, or endorsement by NVLAP, NIST, or any agency of the Federal Government. Analyst(s): Maria Cao Approved By: Michael Zavislak, Approved Signatory NVLAP Lab Code Summit Laboratories, 3575 Centre Circle, Fort Mill, SC 29715, Phone: (704) Page 5 of 5 This is the last page of the report

17

18

19 October 9, 2017 SUMMIT Engineering, Laboratory & Testing, Inc Centre Circle Fort Mill, SC CLIENT PROJECT: 207 W. Liberty St. CEI LAB CODE: T Dear Customer: Enclosed are asbestos analysis results for TEM bulk samples received at our laboratory on October 2, The samples were analyzed for asbestos using transmission electron microscopy (TEM) per Chatfield Method. Sample results containing > 1% asbestos are considered asbestos-containing materials (ACMs) per the EPA regulatory requirements. The detection limit for the TEM Chatfield method is <1% depending on the processed weight and constituents of the sample. Thank you for your business and we look forward to continuing good relations. If you have any questions, please feel free to call our office at Kind Regards, Tianbao Bai, Ph.D., CIH Laboratory Director 730 SE Maynard Road Cary, NC

20 ASBESTOS ANALYTICAL REPORT By: Transmission Electron Microscopy Prepared for SUMMIT Engineering, Laboratory & Testing, Inc. CLIENT PROJECT: 207 W. Liberty St. CEI LAB CODE: T TEST METHOD: Bulk Chatfield EPA 600 / R93 / 116 REPORT DATE: 10/09/17 TEL:

21 ASBESTOS BULK ANALYSIS By: TRANSMISSION ELECTRON MICROSCOPY Client: SUMMIT Engineering, Laboratory & Testing, Inc Centre Circle Fort Mill, SC Project: 207 W. Liberty St. TEM BULK CHATFIELD / EPA 600 / R93 / 116 Client ID Lab ID Material Description Sample Weight (g) Organic Material % Acid Soluble Material % Acid Insoluble Material % Asbestos % Roof-3 Black Asphalt Shingle None T68819 Detected Roof-3 Gray Asphalt Shingle None T68820 Detected Roof-3 Felt Paper None T68821 Detected Tran-3 Felt Paper None T68822 Detected WG-3 Window Glazing None T68823 Detected S Roof-3 Shed Roof None T68824 Detected Page 1 of 2

22 LEGEND: None METHOD: CHATFIELD & EPA/600/R-93/116 LIMIT OF DETECTION: Varies with the weight and constituents of the sample (<1%) REGULATORY LIMIT: >1% by weight This report relates only to the samples tested or analyzed and may not be reproduced, except in full, without written approval by CEI Labs, Inc. CEI Labs makes no warranty representation regarding the accuracy of client submitted information in preparing and presenting analytical results. Interpretation of the analytical results is the sole responsibility of the client. Estimated measurement of uncertainty is available on request. Samples were received in acceptable condition unless otherwise noted. ANALYST: Jennifer Turner APPROVED BY: Tianbao Bai, Ph.D., CIH Laboratory Director Page 2 of 2

23

24

25 AHERA/NESHAP Asbestos Inspection SUMMIT Project No W Liberty Street, Florence, South Carolina October 9, 2017 APPENDIX B ASBESTOS LICENSES C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\Appendix B.rtf

26

27 AHERA/NESHAP Asbestos Inspection SUMMIT Project No W Liberty Street, Florence South Carolina October 9, 2017 APPENDIX C SUMMIT DOCUMENTATION C:\mcao\Documents\LAB ANALYSIS\City of Florence\207 W. Liberty St\Appendix C.rtf

28

29