Transcription

1 CHEMICAL PRODUCT AND COMPANY IDENTIFICATION MATERIAL SAFETY DATA SHEET Page 01 of 05 Part of Kit: Product Type: Aerosol activator 2. COMPOSITION, INFORMATION ON INGREDIENTS Ingredients CAS No. % n-heptane Aldehyde-aniline condensate ISOBUTANE ISOPROPYL ALCOHOL Organocopper compound Ingredients which have exposure limits Exposure Limits (TWA) ACGIH OSHA OTHER Ingredients (TLV) (PEL) n-heptane 400 ppm TWA 500 ppm TWA None 1640 mg/m mg/m3 ISOPROPYL ALCOHOL 400 ppm TWA 400 ppm TWA 400 ppm TWA 983 mg/m3 980 mg/m3 DuPont AEL Organocopper compound Cu 0.2mg/m3fume Cu 0.1mg/m3 TWA None

2 Page 6 of 9 Cu 1 mg/m3 dust Cu 1 mg/m3 dust Exposure Limits (STEL) ACGIH OSHA Ingredients (TLV) (PEL) n-heptane 500 ppm 500 ppm 2050 mg/m mg/m3 ISOPROPYL ALCOHOL 500 ppm 500 ppm 1230 mg/m mg/m3 3. HAZARDS IDENTIFICATION Toxicity: Primary Routes of Entry: Signs and Symptoms of Exposure: Severe eye irritant. Skin irritant. Inhalation irritates nose and throat. Ingestion may irritate digestive tract and cause nausea, vomiting, and diarrhea. Aspiration of material into the lungs can cause chemical pneumonitis, which can be fatal Heptane and isopropanol: Inhalation, ingestion, eye and skin contact. Dizziness, anesthesia, unconsciousness. MATERIAL SAFETY DATA SHEET Page 02 of HAZARDS IDENTIFICATION (continued) Existing Conditions Aggravated by Exposure: Heptane: Preexisting skin conditions, heart conditions, respiratory disorders. Isopropanol: Skin, eye, and respiratory disorders. Literature Referenced Carcinogen Ingredients Target Organ and Other Health Effects NTP IARC OSHA n-heptane CNS IRR NO NO NO Aldehyde-aniline condensate No Data NO NO NO ISOBUTANE CAR CNS LUN NO NO NO ISOPROPYL ALCOHOL ALG BLO CNS IRR KID NO N/A NO Organocopper compound BLO IRR KID LIV NO NO NO Abbreviations N/A Not Applicable BLO Blood CNS Central nervous system KID Kidney LUN Lung ALG Allergen CAR Cardiac IRR Irritant LIV Liver 4. FIRST AID MEASURES Ingestion: Do not induce vomiting. Keep individual calm. Obtain medical attention.

3 Page 7 of 9 Inhalation: Remove to fresh air. If symptoms persist, obtain medical attention. Skin Contact: Wash with soap and water. Eye Contact: Flush at least 15 minutes with water. Obtain medical attention. 5. FIRE FIGHTING MEASURES Flash Point: 25 F (Base only) Method: Estimated Recommended Extinguishing Agents: Carbon dioxide, foam, dry chemical Special Firefighting Procedures: Hazardous Products formed by Fire or Thermal Decomp Irritating organic vapors Unusual Fire or Explosion Hazards: Vapor may travel considerable distance to source ignition and flash back. Heated cans may burst. Explosive Limits: MATERIAL SAFETY DATA SHEET Page 03 of FIRE FIGHTING MEASURES (continued) (% by volume in air)lower 1.1% Heptane 1.8% Isobutane 2.0% Isopropyl alcohol (% by volume in air)upper 6.7% Heptane 8.4% Isobutane 12.7% Isopropyl alcohol 6. ACCIDENTAL RELEASE MEASURES Steps to be taken in case of spill or leak: Maintain good ventilation. Avoid ignition sources. Soak up remainder in an inert absorbent and store in a closed container until disposal. 7. HANDLING AND STORAGE Safe Storage: Store below 100 F in a tightly closed container away from oxidizing materials and sources of ignition. (Contact Loctite Customer Service for shelf life information) Handling: Keep away from flame. Avoid prolonged breathing of vapors. Avoid skin or eye contact. 8. EXPOSURE CONTROLS, PERSONAL PROTECTION Eyes: Skin: Ventilation: Safety glasses or goggles. Rubber or plastic gloves. Sufficient to maintain vapor concentration

4 Page 8 of 9 Respiratory below TLV. 9. PHYSICAL AND CHEMICAL PROPERTIES See Section 2 for Exposure Limits. Appearance: Odor: Boiling Point: ph: Solubility in Water: Specific Gravity Volatile Organic Compound (EPA Method 24) Vapor Pressure: Vapor Density: Evaporation Rate (Ether = 1) Amber liquid Aliphatic Estimated: 122 F (Base only) Does not apply Immiscible (Base only) 83.84; grams per liter of material Estimated: 35 mm at 68 F (Base only) MATERIAL SAFETY DATA SHEET Page 04 of STABILITY AND REACTIVITY Stability: Hazardous Polymerization: Incompatibility: Conditions to Avoid: Hazardous Decomposition Products (non-thermal): Stable Will not occur Strong oxidizers, strong acids or bases, selected amines, peroxides, acid chlorides, acid anhydrides alkali metals, ammonia. None 11. TOXICOLOGICAL INFORMATION 12. ECOLOGICAL INFORMATION 13. DISPOSAL CONSIDERATIONS Recommended methods of disposal: See Section 3. No data available Use disposal service licensed to handle flammable aerosols. EPA Hazardous Waste Number D001 - Hazardous waste per 40CFR TRANSPORTATION INFORMATION DOT (49 CFR 172) Domestic Ground Transport

5 Page 9 of 9 Proper Shipping Name: Consumer Commodity Hazard Class or Division: ORM-D Identification Number: UN 1950 Marine Pollutant: None IATA Proper Shipping Name: Aerosols, flammable Class or Division: Division 2.1 UN or ID Number: UN REGULATORY INFORMATION CA Proposition 65: No Proposition 65 chemicals are known to be present. MATERIAL SAFETY DATA SHEET Page 05 of OTHER INFORMATION Estimated NFPA(R) Code: Health Hazard: 1 Fire Hazard: 4 Reactivity Hazard: 0 Specific Hazard: Does not apply Estimated HMIS(R) Code: Health Hazard: 1 Flammability Hazard: 4 Reactivity Hazards: 0 Personal Protection: See Section 8. NFPA is a registered HMIS is a registered trademark of the National Fire Protection Assn. trademark of the National Paint and Coatings Assn. Prepared By: Stephen Repetto Title: Research Chemist; Safety,Health&Regulatory Affairs Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT (24hr.) Phone: (860) Revision Date: January 26, 1999 Revision: 0004 application assistance. browse catalog. troubleshooting. equipment datasheets. distributor locator.what's new. career opportunities about loctite. contact loctite. literature. loctite world wide. search. home copyright Loctite