AA1C AIR CONDITIONER SS-AA1C-03

Transcription

1 VILLE SIZES: NMINL SEER RTINGS: ERTIFITIN: ELETRIL RNGE: MPRESSR PRTETIN: FN MTR: IL DESIGN: 1 18,000 to 60,000 tuh UL, c-ul, RI, and E Listed v, 60 Hertz, 1 Phase Each compressor is protected with internal temperature- and current-sensitive overloads. n internal pressure relief valve provides high-pressure protection to the refrigerant system. Totally enclosed for greater reliability under rain conditions. Permanent split-capacitor-type for economical operation. opper tube, enhanced sine wave aluminum fin for optimum heat transfer. Vertical air discharge carries sound FETURES and hot condenser air away from adjacent patio areas and foliage. SERVIE VLVES: rass front seating type with sweat connections externally located for quick and easy connections. Each valve has a service port for ease of checking operating refrigerant pressures. SERVIEILITY: ne access panel provides access to electrical controls. Removal of top gives access to fan motor, condenser coil, and compressor. INET: The top and access panels are protected with a galvanized coating and treated with a layer of zinc phosphate. coat of modified polyester powder coating is then applied and baked-on, providing unit with a hard, smooth finish that will last for years. 1 IR NDITINER SS-1-03

2 1 METERING DEVIE PISTN* UNIT SIZE-SERIES IDENTIFITIN N. 018-, ,, , , D , UNITRY IR NDITINING MNUFTURER ERTIFIED T RI S MPLYING WITH RI EQUIPMENT STNDRD 210 ERTIFITIN PPLIES NLY WHEN THE MPLETE SYSTEM IS LISTED WITH RI. ERTIFITIN F MNUFTURING SITE. 2

3 UNIT SERIES D ELETRIL HRTERISTIS X X X X X X X X X X X X X X X X X X / D E F G H J K L M N P SHIPPING WEIGHT In. In. In. In. In. In. In. In. In. In. In. In. In. In. Lb X = YES = N M IR IN IR DISHRGE SQ IR DISHRGE IR IN N 3 /8 IN. DI TIEDWN KNKUTS (2) PLES J K L IR IN FIELD PWER SUPPLY NN 7 / 8 IN. DI HLE WITH 1 1 / 8 IN. DI KNKUT ND 1 3 / 8 IN. DI KNKUT FIELD NTRL SUPPLY NN 7 / 8 IN. DI HLE 3 / 8 IN. DI LIQUID LINE NN IR DISHRGE UNIT SIZE 18, 24 30, 36, 42 48, 60 E MINIMUM MUNTING PD DIMENSINS (In.) 18 x x x 30 IR IN F G H P D DI VPR LINE NN 1 1 /4 2 7 /8 NTES: 1. llow 30 In. clearance to service side of unit, 48 In. above unit, 6 In. on one side, 12 In. on remaining side, and 24 In. between units for proper airflow. 2. Minimum outdoor operating ambient in cooling mode is 55 F, max. 125 F. 3. Series designation is the 14th position of the unit model number. 4. enter of gravity

4 See notes on page 5. 1 SPEIFITINS UNIT SIZE-SERIES 018-/ 024-// 030-// perating Weight (Lb) 113/ /124/138 ELETRIL Unit Volts Hertz Phase perating Voltage Range* ompressor Rated Load mps 8.0/ /10.9/ /12.9/14.8 Locked Rotor mps 49.0/ /61.0/ /71.0/73.0 ondenser Fan Motor Full Load mps Min Unit mpacity for Wire Sizing 10.8/ /14.5/ /16.9/19.3 Min Wire Size (60 /75 opper) WG 14/14 Max Wire Length (60 /75 ) (Ft) 70/65 55/50 / 50/50 40/40 / 45/40 Max ranch ircuit Fuse Size** MPRESSR & REFRIGERNT ompressor Manufacturer Tecumseh/ristol opeland/tecumseh/ristol Type Reciprocating Temperature and urrent Protection Internal Line reak Refrigerant R22 Ft (Lb) 3.44/ /3.82/ /4.46/4.75 Refrigerant Tubes (In. D) Vapor and Liquid (Up to 50 Ft) 5/8 and 3/8 3/4 and 3/8 NDENSER IL & FN oil Face rea (Sq Ft) 5.6/ /6.9/ /7.4/8.28 Fan Motor PS Type, HP and RPM 1/8 and 00 1/6 and 00 1/10 and 1125 Volts Hertz Phase 208/ ondenser irflow (FM) PTINL EQUIPMENT oastal Filter KF0601SML KF0401MED Start ssist apacitor/relay Type KSHS0301 / KSHS0401 KSHS0601 / KSHS0301 / KSHS0401 Start ssist PT Type KS0201PT High-Pressure Switch KSHI0101HPS Low-Pressure Switch KLP0101LPS Low-mbient ontroller (RD) P Evaporator Freeze Thermostat KFT0101 Winter Start ontrol KWS0101 Sound Hood N/ N/ / KSSH1301TE / KSSH2001RL rankcase Heater KH1001 Time-Delay Relay KTD0101TDR Filter Drier (RD) P S Liquid Line Solenoid Valve KLS0101LLS ycle Protector KSY0101 TXV (RP) KTX0201RP KTX0301RP KTX0401RP TXV (Hard Shutoff) KTX0901HS KTX1001HS KTX1101HS MotorMaster ontrol N/ 32LT (RD) all earing Fan Motor N/ H34GE231 (RD) Thermostat, uto hangeover, Non-Programmable, F/, 1-Stage Heat, 1-Stage ool TSTTXXN01-*** Thermostat, uto hangeover, 7-Day Programmable, F/, 1-Stage Heat, 1-Stage ool TSTTXXP01-*** Thermostat, Manual hangeover, Non-Programmable, F, 1-Stage Heat, 1-Stage ool --HH--07T-213 () HH07T212 (DP) utdoor Sensor TSTTSEN01 () TSTTSEN01 (DP) 4

5 1 SPEIFITINS ontinued UNIT SIZE-SERIES 036-///D 042-/ 048-/ 060-/ perating Weight (Lb) 129/133/ / ELETRIL Unit Volts Hertz Phase perating Voltage Range* ompressor Rated Load mps 16.7/14.8/.7/ / / /28.8 Locked Rotor mps 95.0/86.0/86.0/ / / /169.0 ondenser Fan Motor Full Load mps Min Unit mpacity for Wire Sizing 22.3/19.9/21.0/ / / /37.4 Min Wire Size (60 /75 opper) WG 12/12 10/10 8/10 8/8 Max Wire Length (60 /75 ) (Ft) 55/50 / 55/55 70/70 / 75/70 95/55/100/60 80/75 Max ranch ircuit Fuse Size** MPRESSR & REFRIGERNT ompressor Manufacturer Millennium/opeland/ Tecumseh/ristol Millennium/opeland Type Scroll/Reciprocating/ Reciprocating/ Reciprocating Scroll/Reciprocating Scroll Temperature and urrent Protection Internal Line reak Refrigerant R22 Ft (Lb) 4.63/5.00/4.78/ / / /8.46 Refrigerant Tubes (In. D) Vapor and Liquid (Up To 50 Ft) 3/4 and 3/8 7/8 and 3/8 1-1/8 and 3/8 NDENSER IL & FN oil Face rea (Sq Ft) 9.0/9.0/8.2/ /16.1 Fan Motor PS Type, HP and RPM 1/4 and /4 and /4 and 1100 Volts Hertz Phase 208/ ondenser irflow (FM) PTINL EQUIPMENT oastal Filter KF0401MED KF0401MED KF0501LRG Start ssist apacitor/relay Type Start ssist PT Type High-Pressure Switch Low-Pressure Switch N/ /KSHS0601/ KSHS0301/ KSHS0401 KSHS0401/ KSHS0701 KS0201PT KSHI0101HPS KLP0101LPS Low-mbient ontroller (RD) P Evaporator Freeze Thermostat KFT0101 Winter Start ontrol KWS0101 Sound Hood rankcase Heater Time-Delay Relay KSSH1901YL/ KSSH1201P / N// KSSH2001RL KH1201/ KH1001/ KH1001/ KH1001 KSSH1901YL/ KSSH1201P KH1201 KH1001 KTD0101TDR KSHS0401/KSHS0801 KSSH2001YL / KSSH2101P KH1201 Filter Drier (RD) P S P S Liquid Line Solenoid Valve KLS0101LLS Standard/KSY0101/KSY0101/ ycle Protector KSY0101 Standard TXV (RP) KTX0501RP KTX0601RP KTX0701RP TXV (Hard Shutoff) KTX1201HS KTX1301HS KTX1401HS MotorMaster ontrol 32LT all earing Fan Motor H40GE230 Thermostat, uto hangeover, Non-Programmable, F/, 1-Stage Heat, 1-Stage ool TSTTXXN01-*** Thermostat, uto hangeover, 7-Day Programmable, F/, 1-Stage Heat, 1-Stage ool TSTTXXP01-*** Thermostat, Manual hangeover, Non-Programmable, F, 1-Stage Heat, 1-Stage ool --HH--07T-213 () HH07T212 (DP) utdoor Sensor TSTTSEN01 () TSTTSEN01 (DP) * Permissible limits of the voltage range at which unit will operate satisfactorily. peration outside these limits may result in unit failure. If wire is applied at ambient greater than 30 (86 F), consult Table of the NE (NSI/NFP 70). The ampacity of nonmetallic-sheathed cable (NM), trade name RMEX, shall be that of 60 (140 F) conductors, per the NE (NSI/NFP 70) rticle If other than uncoated (non-plated), 60 or 75 (140 or 167 F) insulation, copper wire (solid wire for 10 WG and smaller, stranded wire for larger than 10 WG) is used, consult applicable tables of the NE (NSI/NFP 70). Length shown is as measured 1 way along wire path between unit and service panel for voltage drop not to exceed 2%. ** Time-delay fuse or HR-type circuit breaker. Start assist capacitor and relay required when using liquid solenoid valve or hard shutoff TXV (except 036 and 042, Series ; 048 and 060, all series). Do not use hard shutoff TXV with liquid solenoid valve. Use with low-ambient controller. *** Where XX appears, insert for ryant, for arrier, DD for Day & Night, or PP for Payne brand. N/ Not pplicable NTES: 1. ll motors/compressors contain internal overload protection. 2. opper wire must be used from service disconnect to unit. 3. ontrol circuit is 24v on all units and requires external power source. 5

6 UNIT SIZE-SERIES 018-, 024-,, 030-,, 036-,,, D See notes on page 7. 1 RTINGS ND PERFRMNE FTRY- TTL SUPPLIED FIELD-SUPPLIED SUND INDR PITY ENHNE- STNDRD ESSRY RTING MDEL TUH MENT RTING TDR TXV (d) 5/D5/D5018* 17,200 NNE /D5/D ,600 NNE /D5/D5W024 17,600 NNE D3(,)018 17,200 NNE D3(,)024 17,600 NNE D ,600 NNE E ,800 NNE F ,800 NNE G ,800 TXV F(,)4NF018 17,000 TDR F(,)4NF024 17,600 TDR F4NF024 17,600 TDR&TXV F4NF033 17,600 TDR&TXV FD3N018 17,100 NNE FD3N024 17,600 NNE FF1(,)N018 17,200 TDR FF1(,)N024 17,600 TDR FG ,500 NNE FK4NF001 17,600 TDR&TXV FK4NF002 17,600 TDR&TXV /D5/D5024* 22,400 NNE /D5/D ,600 NNE /D5/D5W024 22,400 NNE /D5/D5W030 22,600 NNE D3(,)024 22,400 NNE D3(,)030 22,600 NNE D ,600 NNE D ,600 NNE E ,600 NNE E ,000 NNE F ,600 NNE G ,600 TXV F(,)4NF024 22,600 TDR F(,)4NF030 23,000 TDR F4NF024 22,600 TDR&TXV F4NF030 23,000 TDR&TXV F4NF033 23,400 TDR&TXV FD3N024 22,200 NNE FD3N030 23,000 NNE FF1(,)N024 22,600 TDR FF1(,)N030 23,200 TDR FG ,000 NNE FK4NF001 23,200 TDR&TXV FK4NF002 23,400 TDR&TXV FK4NF003 23,600 TDR&TXV /D5/D5030* 28,000 NNE /D5/D ,000 NNE /D5/D5W030 28,000 NNE D3(,)030 28,000 NNE D3(,)036 29,000 NNE D ,800 NNE D ,000 NNE D5/D5W036 29,000 NNE E ,800 NNE E ,600 NNE F ,800 NNE G ,800 TXV F(,)4NF030 27,600 TDR F(,)4NF036 28,200 TDR F4NF030 27,600 TDR&TXV F4NF033 29,000 TDR&TXV F4NF036 28,200 TDR&TXV FD3N030 27,800 NNE FF1(,)N030 28,000 TDR FG ,000 NNE FK4NF001 29,000 TDR&TXV FK4NF002 29,200 TDR&TXV FK4NF003 29,400 TDR&TXV /D5/D5036* 33,800 NNE /D5/D ,800 NNE /D5/D5W042 33,800 NNE D3(,)036 33,800 NNE D3(,)042 33,800 NNE D ,400 NNE D ,400 NNE D5/D5W036 33,800 NNE E ,400 NNE E ,600 NNE F ,600 NNE G ,600 TXV F(,)4N(F,)042 33,800 TDR F(,)4NF036 33,000 TDR F4N(F,)042 33,800 TDR&TXV F4N054 34,800 TDR&TXV F4NF033 33,800 TDR&TXV F4NF036 33,000 TDR&TXV

7 UNIT SIZE-SERIES 036-,,, D 042-, 048-, 060-, 1 RTINGS ND PERFRMNE ontinued FTRY- TTL SUPPLIED FIELD-SUPPLIED SUND INDR PITY ENHNE- STNDRD ESSRY RTING MDEL TUH MENT RTING TDR TXV (d) F4NF038 34,800 TDR&TXV FG ,600 NNE FK4N006 35,200 TDR&TXV FK4NF001 33,000 TDR&TXV FK4NF002 33,000 TDR&TXV FK4NF003 33,600 TDR&TXV FK4NF005 35,000 TDR&TXV /D5/D ,000 NNE /D5/D ,500 NNE /D5/D5W042 40,000 NNE /D5/D5W048 40,000 NNE D3(,)042 40,000 NNE D3(,)048 40,000 NNE D ,000 NNE D5/D ,000 NNE E ,500 NNE E ,500 NNE G ,500 TXV F(,)4N(F,)042 40,000 TDR F(,)4N(F,)048 41,000 TDR F4N(F,)042 40,000 TDR&TXV F4N(F,)048 41,000 TDR&TXV F4N054 41,500 TDR&TXV F4NF038 41,500 TDR&TXV FG ,000 NNE FK4NF003 40,000 TDR&TXV FK4NF005 41,000 TDR&TXV FK4NF006 41,500 TDR&TXV /D5/D ,000 NNE /D5/D ,000 NNE /D5/D5W048 46,000 NNE /D5/D5W060 47,500 NNE D3(,)048 46,000 NNE D3(,)060 46,000 NNE D ,500 NNE D5/D ,000 NNE E ,500 NNE E ,000 NNE F ,000 NNE G ,000 TXV F(,)4N(F,)048 47,000 TDR F(,)4N(F,)060 48,000 TDR F4N070 49,000 TDR F4NF006 49,000 TDR F4N(F,)048 47,000 TDR&TXV F4N(F,)060 47,500 TDR&TXV F4N054 48,500 TDR&TXV F4N070 48,500 TDR&TXV FG ,000 NNE FG ,000 NNE FK4NF005 48,000 TDR&TXV /D5/D ,500 NNE /D5/D5W060 57,000 NNE D3(,)060 54,500 NNE D ,000 NNE E ,500 NNE F(,)4N(F,)060 57,500 TDR F4N070 58,000 TDR F4N(F,)060 57,000 TDR&TXV F4N054 57,500 TDR&TXV F4N070 58,000 TDR&TXV FG ,500 NNE FK4N006 58,000 TDR&TXV * Tested combination. TXV must be hard shutoff type. TDR Time-Delay Relay TXV Thermostatic Expansion Valve NTES: 1. Ratings are net values reflecting the effects of circulating fan motor heat. Supplemental electric heat is not included. 2. Tested outdoor/indoor combinations have been tested in accordance with DE test procedures for central air conditioners. Ratings for other combinations are determined under DE computer simulation procedures. 3. Determine actual FM values obtainable for your system by referring to fan performance data in fan coil or furnace coil literature. 7

8 SYSTEM DESIGN 1. Intended for outdoor installation with free air inlet and outlet. utdoor fan external static pressure available is less than 0.01-in. wc. 2. Minimum outdoor operating air temperature without low-ambient operation accessory is 55 F (12.8 ). 3. Maximum outdoor operating air temperature is 1 F (46.1 ). 4. For reliable operation, unit should be level in all horizontal planes. 5. Maximum elevation of indoor coil above or below base of outdoor unit is: indoor coil above = 50 ft, indoor coil below = 0 ft. (See items 6 and 7 following.) 6. For interconnecting refrigerant tube lengths greater than 50 ft, consult your local distributor. 7. rankcase heater required when interconnecting refrigerant tube length exceeds 50 ft. 8. Not more than 36 in. of refrigerant tube should be buried in the ground. If necessary to bury tubes under a sidewalk, provide a minimum 6-in. vertical rise to the valve connections at the unit. 9. Use only copper wire for electric connection at unit. luminum and clad aluminum are not acceptable for the type of connector provided. SERVIE TRINING Packaged Service Training programs are an excellent way to increase your knowledge of the equipment discussed in this manual, including: Unit Familiarization Maintenance Installation verview perating Sequence large selection of product, theory, and skills programs is available, using popular video-based formats and materials. ll include video and/or slides, plus companion book. lassroom Service Training plus "hands-on" the products in our labs can mean increased confidence that really pays dividends in faster troubleshooting, fewer callbacks. ourse descriptions and schedules are in our catalog. LL FR FREE TLG [ ] Packaged Service Training [ ] lassroom Service Training SPEIFITINS SUJET T HNGE WITHUT NTIE UNIT MUST E INSTLLED IN RDNE WITH INSTLLTIN INSTRUTINS ancels: New / DP P.. ox 70, Indianapolis, IN atalog No PRINTED IN U.S